UFGS-09 30 16.00 40
QUARRY TILING
inactive, Most Current
| Publication Date: | 1 October 2006 |
| Status: | inactive |
| Page Count: | 14 |
Document History
UFGS-09 30 16.00 40
October 1, 2006
QUARRY TILING
A description is not available for this item.
References
This document references:
C150/C150M - Standard Specification for Portland Cement
July 1, 2022
This specification covers ten types of portland cement, as follows (see Note 2): Type I—For general use, when the special properties specified for any other type are not required. Type...
This document references:
ASTM D226/D226M - Standard Specification for Asphalt-Saturated Organic Felt Used in Roofing and Waterproofing
Published by ASTM
on
June 15, 2017
This specification covers asphalt-saturated organic felts, with or without perforations, intended to be used with asphalts conforming to the requirements of Specification D312/D312M in the...
This document references:
ASTM C920 - Standard Specification for Elastomeric Joint Sealants
Published by ASTM
on
January 1, 2018
This ASTM specification covers the properties of a cured single- or multicomponent cold-applied elastomeric joint sealant for sealing, caulking, or glazing operations on buildings, plazas, and decks...
This document references:
ASTM C207 - Standard Specification for Hydrated Lime for Masonry Purposes
Published by ASTM
on
November 1, 2018
This specification covers four types of hydrated lime. Types N and S are suitable for use in mortar, in scratch and brown coats of cement plaster, for stucco, and for addition to portland-cement...
This document references:
ASTM C847 - Standard Specification for Metal Lath
Published by ASTM
on
October 1, 2018
This specification covers sheet lath, expanded metal lath, diamond mesh, flat and self-furring, and rib metal lath, 1⁄8 and 3⁄8 in. (3.2 and 9.6 mm), all with or without factoryattached...
This document references:
ASTM C206 - Standard Specification for Finishing Hydrated Lime
Published by ASTM
on
December 1, 2014
This specification covers two types of finishing hydrated lime that are suitable for use in the scratch, brown, and finish coats of plaster, for stucco, for mortar, and as an addition to...
This document references:
C241/C241M - Standard Test Method for Abrasion Resistance of Stone Subjected to Foot Traffic
November 15, 2021
This test method covers the determination of abrasion resistance of all types of stones for floors, steps, and similar uses where the wear is caused by foot traffic. The values stated in either SI...
This document references:
ASTM D1056 - Standard Specification for Flexible Cellular Materials—Sponge or Expanded Rubber
Published by ASTM
on
October 1, 2020
This specification covers flexible cellular rubber products known as sponge rubber and expanded rubber, but does not apply to latex foam rubber or ebonite cellular rubber. The base material for an...
This document references:
D2103 REV A - Standard Specification for Polyethylene Film
December 1, 2023
This specification covers the classification of polyethylene film up to 0.254 mm (0.010 in.) in thickness, inclusive. The film can contain additives for the improvement of the surface properties,...