UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS C 9

Specification for Coupling Dimensions for High Pressure Air Charging Valves for Aircraft

active, Most Current
Buy Now
Organization: BSI
Publication Date: 31 March 1970
Status: active
Page Count: 2
ICS Code (Ground service and maintenance equipment): 49.100

Document History

BS C 9
March 31, 1970
Specification for Coupling Dimensions for High Pressure Air Charging Valves for Aircraft
A description is not available for this item.

References

This document references:
BS 350 - Conversion factors for units
Published by BSI on May 25, 2004
A description is not available for this item.
This document references:
BS 2856 - Precise Conversion of Inch and Metric Sizes on Engineering Drawings
Published by BSI on October 8, 1973
Provides a procedure for the conversion of inch and metric sizes on engineering drawings which will give the essential accuracy required for precise dimensional interchangeability. The standard gives...
This document is referenced by:
DEF STAN 00-970: PT1 SEC6 - Design and Airworthiness Requirements for Service Aircraft Part 1: Fixed Wing Section 6: Equipment
Published by MODUK on September 19, 2016
INTRODUCTION This Clause specifies the requirements relating to equipment and systems embodied on any aircraft. These requirements are to be used where there are no aircraft specific requirements...
This document is referenced by:
DEF STAN 00-970: V1 B2 P4 - Design and Airworthiness Requirements for Service Aircraft Volume 1 - Aeroplanes Book 2 (Parts 4 to 6 and Chapters 700 to 710) Part 4: Detail Design and Strength of Materials
Published by MODUK on October 1, 1992
GENERAL In the detailed design of the aeroplane the variety of materials and parts to be kept to a minimum consistent with structural efficiency and without unduly sacrificing structure weight. The...
This document is referenced by:
DEF STAN 00-970: V2 P7 - Design and Airworthiness Requirements for Service Aircraft Volume 2 - Rotorcraft Book 3 (Parts 7 to 10) Part 7: Installations
Published by MODUK on March 10, 1998
INTRODUCTION The requirements of this Chapter are applicable to the design and construction of all turbine engine propulsion system installations including all the equipment and sub-systems necessary...
This document is referenced by:
DEF STAN 00-970 PT7: VOL1 - Installations Chapter 711 on
Published by MODUK on March 10, 1998
This chapter states the design requirements for the installation of armament equipment in all aeroplanes. Armament Equipment, for the purpose of these requirements , comprises the weapon...
This document is referenced by:
DEF STAN 00-970: PART 1 - Certification Specifications for Airworthiness Part 1: FIXED WING COMBAT AIR SYSTEMS
Published by MODUK on August 28, 2020
Note 1 Where CS 25 and CS 23 make reference to ‘the Agency’, this should be considered to mean the certifying authority.
View Less
View All

Related Products

Searching for related products...

Advertisement