UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

NPFC - MS 21949

BOLT-CLUSTER FITTING, SINGLE PORT-FLARE

active, Most Current
Buy Now
Organization: NPFC
Publication Date: 14 August 2014
Status: active
Page Count: 4

Document History

MS 21949
August 14, 2014
BOLT-CLUSTER FITTING, SINGLE PORT-FLARE
A description is not available for this item.
MS 21949
September 20, 2000
BOLT-CLUSTER FITTING, SINGLE PORT-FLARE
This specification is approved for use by all Departments and Agencies of the Department of Defense .
MS21949 REV A
May 13, 1966
BOLT-CLUSTER FITTING, SINGLE PORT-FLARE
A description is not available for this item.

References

This document references:
ASME B46.1 - Surface Texture (Surface Roughness, Waviness, and Lay)
Published by ASME on January 1, 2019
This Standard is concerned with the geometric irregularities of surfaces. It defines surface texture and its constituents: roughness, waviness, and lay. It also defines parameters for specifying...
This document references:
MS21932 REV C - FITTING END, BOLT CLUSTER FITTING, SINGLE PORT
Published by NAVY on July 27, 1987
This military standard is approved for use by all Departments & Agencies of the Department of Defense. Selection for all new engineering and design applications and for repetitive use shall be made...
This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME on January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
This document is referenced by:
MS 21931 - FITTING INSTALLATION, CLUSTER
Published by NPFC on April 19, 2012
This specification sheet is intended for use in type II aircraft hydraulic power systems, operating pressure 3000 PSI as specified in SAE-AS18280.
View Less
View All
Advertisement