This document references:
ACI 551.2R - Design Guide for Tilt-Up Concrete Panels
Published by ACI
on
August 1, 2015
INTRODUCTION Tilt-up concrete buildings have been constructed in North America for over 100 years, but it was not until the late 1990s that ACI 318 specifically addressed the requirements for design...
This document references:
301 - Specifications for Concrete Construction (ACI 301-20)
Published by ACI
on
September 1, 2020
This Specification covers construction of cast-inplace concrete, architectural concrete, lightweight concrete, mass concrete, post-tensioned concrete, shrinkage-compensating concrete for interior...
This document references:
301 - Specifications for Concrete Construction (ACI 301-20)
Published by ACI
on
September 1, 2020
This Specification covers construction of cast-inplace concrete, architectural concrete, lightweight concrete, mass concrete, post-tensioned concrete, shrinkage-compensating concrete for interior...
This document references:
ACI 302.1R - Guide to Concrete Floor and Slab Construction
Published by ACI
on
June 1, 2015
This guide emphasizes choosing and proportioning of materials, design details, proper construction methods, and workmanship. Slabs specifically intended for the containment of liquids are beyond the...
This document references:
ACI 304.2R - Guide to Placing Concrete by Pumping Methods
Published by ACI
on
October 1, 2017
This guide for concrete pumping discusses equipment use, proper mixtures for good pumpability, and field practices. References cited provide more detailed information on specific subjects. This guide...
This document references:
ACI 551.2R - Design Guide for Tilt-Up Concrete Panels
Published by ACI
on
August 1, 2015
INTRODUCTION Tilt-up concrete buildings have been constructed in North America for over 100 years, but it was not until the late 1990s that ACI 318 specifically addressed the requirements for design...
This document is referenced by:
UFGS-03 47 13 - TILT-UP CONCRETE
August 1, 2008
NOTE: This specification covers the requirements for tilt-up concrete wall panels precast on a previously prepared casting bed, usually the floor slab, and erection with a crane by tilting to a near...
This document is referenced by:
ACI 233R - Guide to the Use of Slag Cement in Concrete and Mortar
Published by ACI
on
September 1, 2017
Scope and objective The objective of this report is to compile and to present experiences in research and field use of slag cement in concrete and mortar, and to offer guidance in its specification,...
This document is referenced by:
ACI 332.1R - Guide to Residential Concrete Construction
Published by ACI
on
May 1, 2018
This guide provides practical information about the construction of residential concrete that meets or exceeds code requirements, covering all concrete work within the scope defined in the...