GMW15283
Cycle - Immersion Corrosion Test for Stainless Steel Molding Materials
inactive
Buy Now
| Organization: | GMW |
| Publication Date: | 1 April 2016 |
| Status: | inactive |
| Page Count: | 4 |
scope:
Purpose. This standard describes a test procedure intended to simulate the corrosive environment encountered by the exterior stainless steel moldings on automobiles operating where highly corrosive agents are used for winter road deicing and/or where high corrosion load near coastal regions does exist.
Document History
May 1, 2020
Cycle - Immersion Corrosion Test for Stainless Steel Molding Materials
Purpose.
This standard describes a test procedure intended to simulate the corrosive environment encountered by the exterior stainless steel moldings on automobiles operating where highly corrosive...
GMW15283
April 1, 2016
Cycle - Immersion Corrosion Test for Stainless Steel Molding Materials
Purpose. This standard describes a test procedure intended to simulate the corrosive environment encountered by the exterior stainless steel moldings on automobiles operating where highly corrosive...
September 1, 2011
Cycle - Immersion Corrosion Test for Stainless Steel Molding Materials
Note: Nothing in this standard supercedes applicable laws and regulations.
Note: In the event of conflict between the English and domestic language, the English language shall take precedence....
August 1, 2006
Cycle - Immersion Corrosion Test for Stainless Steel Molding Materials
Note: Nothing in the specification supersedes applicable laws and regulations unless specific exemption has been obtained.
Note: In the event of conflict between the English and domestic language,...