UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

SNV - SN EN 14420-8+A1

Hose fittings with clamp units - Part 8: Symmetrical half coupling (Guillemin system)

active, Most Current
Organization: SNV
Publication Date: 1 May 2016
Status: active
Page Count: 19
ICS Code (Hoses and hose assemblies): 23.040.70

Document History

SN EN 14420-8+A1
May 1, 2016
Hose fittings with clamp units - Part 8: Symmetrical half coupling (Guillemin system)
A description is not available for this item.
SN EN 14420-8
October 1, 2013
Hose fittings with clamp units - Part 8: Symmetrical half coupling (Guillemin system)
This European Standard specifies dimensions, types of connections, quality of materials, marking requirements and testing requirements for hose fittings with symmetrical half couplings (Guillemin...
SN EN 14420-8
February 1, 2005
Hose fittings with clamp units - Part 8: Symmetrical half coupling (Guillemin system)
A description is not available for this item.

References

This document references:
ISO 228-1 - Pipe Threads Where Pressure-Tight Joints Are Not Made on the Threads - Part 1: Dimensions, Tolerances and Designation
Published by ISO on September 1, 2000
This part of ISO 228 specifies the requirements for thread form, dimensions, tolerances and designation for fastening pipe threads, thread sizes 1/16 to 6 inclusive. Both internal and external...
This document references:
ISO 4957 - Tool steels
Published by ISO on June 1, 2018
This document specifies requirements for the following grades of wrought tool steels: a) non-alloy cold-work tool steels; b) alloy cold-work tool steels; c) alloy hot-work tool steels; d) high-speed...
This document references:
ISO 2768-1 - General Tolerances - Part 1: Tolerances for Linear and Angular Dimensions without Individual Tolerance Indications First Edition; (CEN EN 22768-1: 1993)
Published by ISO on January 1, 1989
This part of ISO 2766 is intended to simplify drawing indications and it specifies general tolerances for linear and angular dimensions without individual tolerance indications in four tolerance...
This document references:
ISO 6708 - Pipework Components - Definition and Selection of DN (Nominal Size); (CEN EN ISO 6708: 1995)
Published by ISO on January 1, 1995
This International Standard gives the definition of DN (nominal size) when applied to components of a pipework system, as specified in those standards which use the DN designation system. NOTE 1...
View Less
View All
Advertisement