UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

NPFC - MS 27622

SOCKET, HOSE COUPLING

active, Most Current
Buy Now
Organization: NPFC
Publication Date: 12 January 2018
Status: active
Page Count: 7

Document History

MS27622 REV C VALID NOTICE 1
December 7, 2022
Socket, Hose Coupling
A description is not available for this item.
MS 27622
January 12, 2018
SOCKET, HOSE COUPLING
A description is not available for this item.
MS 27622
October 14, 2009
SOCKET, HOSE COUPLING
A description is not available for this item.
MS 27622
September 29, 2000
SOCKET, HOSE COUPLING
This specification is approved for use by all Departments and Agencies of the Department of Defense. The requirements for acquiring the product described herein shall consist of this specification...
MS27622
March 17, 1971
SOCKET, HOSE COUPLING
A description is not available for this item.

References

This document references:
ASME B46.1 - Surface Texture (Surface Roughness, Waviness, and Lay)
Published by ASME on January 1, 2019
This Standard is concerned with the geometric irregularities of surfaces. It defines surface texture and its constituents: roughness, waviness, and lay. It also defines parameters for specifying...
This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME on January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
This document references:
MS 27616 - ADAPTER ASSEMBLY, FLARED, STRAIGHT, TUBE TO HOSE-WITH SWIVEL NUT
Published by NPFC on January 12, 2018
A description is not available for this item.
This document references:
A276/A276M - Standard Specification for Stainless Steel Bars and Shapes
January 1, 2024
This specification covers hot-finished or cold-finished bars except bars for reforging (Note 1). It includes rounds, squares, and hexagons, and hot-rolled or extruded shapes, such as angles, tees,...
This document references:
A473 REV A - Standard Specification for Stainless Steel Forgings
September 1, 2023
This specification covers austenitic, austenitic-ferritic, ferritic, and martensitic stainless steel forgings for general use, and for low- or high-temperature service. The values stated in...
View Less
View All
Advertisement