NEN-EN 10120
Steel sheet and strip for welded gas cylinders
active, Most Current
| Organization: | NEN |
| Publication Date: | 1 August 2017 |
| Status: | active |
| Page Count: | 16 |
| ICS Code (Flat steel products and semi-products): | 77.140.50 |
scope:
NEN-EN 10120 specifies requirements for sheet and strip up to 5 mm thickness of steels listed in Table 1 and intended for the manufacture of welded gas cylinders. The general technical delivery conditions in EN 10021 also apply to products supplied in accordance with this European Standard.
Document History
NEN-EN 10120
August 1, 2017
Steel sheet and strip for welded gas cylinders
NEN-EN 10120 specifies requirements for sheet and strip up to 5 mm thickness of steels listed in Table 1 and intended for the manufacture of welded gas cylinders. The general technical delivery...
November 1, 2014
Steel sheet and strip for welded gas cylinders
NEN-EN 10120 specifies requirements for sheet and strip up to 5 mm thickness of steels listed in Table 1 and intended for the manufacture of welded gas cylinders. The general technical delivery...
October 1, 2008
Steel sheet and strip for welded gas cylinders
NEN-EN 10120 specifies requirements for hot-rolled sheet and strip up to 5 mm thickness of steels listed in Table 1 and intended for the manufacture of welded gas cylinders. The general technical...
October 1, 2008
Steel sheet and strip for welded gas cylinders
NEN-EN 10120 specifies requirements for hot-rolled sheet and strip up to 5 mm thickness of steels listed in Table 1 and intended for the manufacture of welded gas cylinders. The general technical...
February 1, 1997
Steel sheet and strip for welded gas cylinders
This standard specifies requirements for hot-rolled sheet and strip up to 5 mm thickness made of steels suitable for deep drawing as listed in table 1.
February 1, 1997
Steel sheet and strip for welded gas cylinders
This standard specifies requirements for hot-rolled sheet and strip up to 5 mm thickness made of steels suitable for deep drawing as listed in table 1.
July 1, 1994
Steel sheet and strip for welded gas cylinders
This standard specifies requirements for hot-rolled sheet and strip up to 5 mm thickness made of steels suitable for deep drawing as listed in table 1.