UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

AIA/NAS - NASM525

SCREW, WASHER HEAD

inactive
Buy Now
Organization: AIA/NAS
Publication Date: 30 June 2010
Status: inactive
Page Count: 2

Document History

NASM525
December 19, 2014
SCREW, WASHER HEAD
A description is not available for this item.
NASM525
June 30, 2010
SCREW, WASHER HEAD
A description is not available for this item.
NASM525
July 1, 2000
Screw - Washer Head
A description is not available for this item.
NASM525
September 1, 1999
Screw - Washer Head
A description is not available for this item.

References

This document references:
ASTM B221 - Standard Specification for Aluminum and Aluminum-Alloy Extruded Bars, Rods, Wire, Profiles, and Tubes
Published by ASTM on December 1, 2020
This specification2 covers aluminum and aluminum-alloy extruded bars, rods, wire, profiles, and tubes in the aluminum alloys (Note 1) and tempers shown in Table 2. NOTE 1—Throughout this...
This document references:
ASTM B241/B241M - Standard Specification for Aluminum and Aluminum-Alloy Seamless Pipe and Seamless Extruded Tube
Published by ASTM on February 1, 2016
This specification2 covers aluminum and aluminum–alloy seamless pipe in the alloys (Note 1) and tempers shown in Table 1 [Table 2] and seamless extruded round tube in the alloys and tempers shown in...
This document references:
ASTM B308/B308M - Standard Specification for Aluminum-Alloy 6061-T6 Standard Structural Profiles
Published by ASTM on May 1, 2010
This specification2 covers extruded 6061-T6 aluminumalloy standard structural profiles. The profiles are limited to I-beams, H-beams, channels, angles, tees, and zees. NOTE 1—For other extruded...
This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME on January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
View Less
View All
Advertisement