UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS PD ISO/TR 22849

Design recommendations for bevel gears

active, Most Current
Buy Now
Organization: BSI
Publication Date: 31 May 2011
Status: active
Page Count: 46
ICS Code (Gears): 21.200

Document History

BS PD ISO/TR 22849
May 31, 2011
Design recommendations for bevel gears
A description is not available for this item.

References

This document references:
ISO 10825 - Gears - Wear and Damage to Gear Teeth - Terminology
Published by ISO on January 1, 1995
This International Standard defines terms used to describe the appearance of the visible surfaces of tooth flanks or the damage that can be observed on gears. For each term, a clear concise...
This document references:
ISO 10300-1 - Calculation of load capacity of bevel gears - Part 1: Introduction and general influence factors
Published by ISO on April 1, 2014
A description is not available for this item.
This document references:
ISO 10300-2 - Calculation of load capacity of bevel gears - Part 2: Calculation of surface durability (pitting)
Published by ISO on April 1, 2014
A description is not available for this item.
This document references:
ISO TR 14179-1 - Gears - Part 1: Thermal Rating
Published by ISO on January 1, 2001
A description is not available for this item.
This document references:
ISO TR 10064-6 - Code of inspection practice — Part 6: Bevel gear measurement methods
Published by ISO on February 15, 2009
This part of ISO/TR 10064 provides information on measuring methods and practices of unassembled bevel and hypoid gears and gear pairs. Tolerances are provided in Clause 5 of ISO 17485:2006, for...
This document references:
ISO TR 18792 - Lubrication of industrial gear drives
Published by ISO on December 15, 2008
This Technical Report is designed to provide currently available technical information with respect to the lubrication of industrial gear drives up to pitch line velocities of 30 m/s. It is intended...
This document references:
ISO 10300-1 - Calculation of load capacity of bevel gears - Part 1: Introduction and general influence factors
Published by ISO on April 1, 2014
A description is not available for this item.
This document references:
ISO 10300-2 - Calculation of load capacity of bevel gears - Part 2: Calculation of surface durability (pitting)
Published by ISO on April 1, 2014
A description is not available for this item.
This document is referenced by:
BS PD ISO/TR 10064-6 - Code of inspection practice Part 6: Bevel gear measurement methods
Published by BSI on September 30, 2009
A description is not available for this item.
View Less
View All

Related Products

Searching for related products...

Advertisement