This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME
on
January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
This document references:
MIL-PRF-38534 - HYBRID MICROCIRCUITS, GENERAL SPECIFICATION FOR
Published by NPFC
on
December 3, 2019
Scope. This specification establishes the general performance requirements for hybrid microcircuits, multi-chip modules (MCM) and similar devices, and the verification requirements for ensuring that...
This document references:
MIL-STD-3018 - PARTS MANAGEMENT
Published by NPFC
on
June 2, 2015
This standard provides requirements for the implementation of an effective Parts Management Program (PMP) on Department of Defense (DoD) acquisitions. This document supports acquisition strategies...
This document is referenced by:
ASME Y14.100 - Engineering Drawing Practices
Published by ASME
on
November 14, 2017
This Standard establishes the essential requirements and reference documents applicable to the preparation and revision of manual or computer-generated engineering drawings and associated lists,...
This document is referenced by:
ASME Y14.100 - Engineering Drawing Practices
Published by ASME
on
November 14, 2017
This Standard establishes the essential requirements and reference documents applicable to the preparation and revision of manual or computer-generated engineering drawings and associated lists,...