UNLIMITED FREE
ACCESS
TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

ASTM International - ASTM F3771-25

Standard Practice for Utilizing Digital Human Modeling in Exoskeleton Design and Application

active
Buy Now
Organization: ASTM International
Publication Date: 1 November 2025
Status: active
Page Count: 15
ICS Code (Aids and adaptation for moving): 11.180.10
significance And Use:

5.1 This practice guides the user through a selection of digital human modeling methods, various modeling focuses, and available outcomes for use in evaluating the performance of existing... View More

scope:

1.1 This practice provides information about utilizing human digital modeling in the design and evaluation of exoskeletons. This practice specifies:

1.1.1 Basic terminology, definitions, principles, methods, inputs, and expected outputs of digital human modeling (DHM) methods.

1.1.2 Principles of modeling methods and expected outputs for designing new exoskeletons or for new work processes, or both.

1.1.3 Principles of modeling methods and expected outputs for evaluating existing exoskeleton devices and human-exoskeleton collaborative/teaming tasks.

1.1.4 Recommendations of modeling methods and expected outputs for consumers to estimate the benefit of using exoskeleton products in their domain.

1.2 The practice does not describe all the details about the model establishment and parameter determination. Instead, this practice provides audiences with necessary modeling procedures and precautions, and results in an interpretation specifically for device design or evaluation purposes.

1.3 The values stated in SI units are to be regarded as the standard. The values given in the examples are not precisely validated, are provided for information only, and are not considered standard.

1.4 Table of Contents:

Section: Title:
1 Scope
2 Referenced Documents
2.1 ASTM Standards
2.2 Other Standards
3 Terminology
4 Summary of Practice
5 Significance and Use
6 Model Components
6.1 Human Model Classification
6.2 Degrees-of-Freedom
6.3 Exoskeleton CAD Model Development Software
6.4 Model Fitting
6.4.1 General Static Fit in Reality
6.4.2 General Dynamic Fit in Reality
6.4.3 Virtual Fitting in DHM
7 Guide for Modeling Procedure and Results Report
7.1 Level 1 Models
7.2 Level 2 Detail Link-Segment Biomechanical Models
7.3 Level 3 and 4 Models
8 General Guide for Model Selection and Applications
8.2 Model Selection for Designing New Exoskeleton Device Interactive Task/Job
8.3 Model Selection for Simulating Existing Interactive Task/Job
9 Known Issues and General Suggestions
9.1 Fitting: Virtually Perfect vs. Reality
9.2 Contact Point/Joint Between the Human Model and the Exoskeleton Model
10 Keywords

1.5 This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility of the user of this standard to establish appropriate safety, health, and environmental practices and determine the applicability of regulatory limitations prior to use.

1.6 This international standard was developed in accordance with internationally recognized principles on standardization established in the Decision on Principles for the Development of International Standards, Guides and Recommendations issued by the World Trade Organization Technical Barriers to Trade (TBT) Committee.

Document History

ASTM F3771-25
November 1, 2025
Standard Practice for Utilizing Digital Human Modeling in Exoskeleton Design and Application
1.1 This practice provides information about utilizing human digital modeling in the design and evaluation of exoskeletons. This practice specifies: 1.1.1 Basic terminology, definitions, principles,...
Advertisement