UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

NPFC - A-A-59935/1

CONICAL SEALS, CRUSH, 37 DEGREE FLARED TUBE FITTTING, ALUMINUM ALLOY

active, Most Current
Buy Now
Organization: NPFC
Publication Date: 2 October 2013
Status: active
Page Count: 8

Document History

A-A-59935/1 VALID NOTICE 2
July 24, 2023
Conical Seals, Crush, 37 Degree Flared Tube Fitting, Aluminum Alloy
A description is not available for this item.
A-A-59935/1
July 6, 2018
Conical Seals, Crush, 37 Degree Flared Tube Fitting, Aluminum Alloy
A description is not available for this item.
A-A-59935/1
October 2, 2013
CONICAL SEALS, CRUSH, 37 DEGREE FLARED TUBE FITTTING, ALUMINUM ALLOY
A description is not available for this item.

References

This document references:
A-A-59935 - CONICAL SEAL, CRUSH, 37 DEGREE FLARED TUBE FITTING, GENERAL REQUIREMENTS FOR
Published by NPFC on October 2, 2013
This commercial item description (CID) covers the general requirements for conical seal, crush, 37 degree flared tube fitting. Requirements for conical seal, crush, 37 degree flared tube fitting are...
This document references:
ASME B46.1 - Surface Texture (Surface Roughness, Waviness, and Lay)
Published by ASME on January 1, 2019
This Standard is concerned with the geometric irregularities of surfaces. It defines surface texture and its constituents: roughness, waviness, and lay. It also defines parameters for specifying...
This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME on January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
This document references:
B209/B209M REV A - Standard Specification for Aluminum and Aluminum-Alloy Sheet and Plate
December 1, 2021
This specification2 covers aluminum and aluminum-alloy flat sheet, coiled sheet, and plate in the alloys (Note 1) and tempers shown in Tables 2, 3, 4, and 5, and in the following finishes: Plate in...
This document references:
ASTM B545 - Standard Specification for Electrodeposited Coatings of Tin
Published by ASTM on May 1, 2013
This specification covers the requirements for electrodeposited (electroplated) coatings of tin applied to metallic articles. Tin coatings are used to provide a low contactresistance surface, to...
This document references:
A-A-59935 - CONICAL SEAL, CRUSH, 37 DEGREE FLARED TUBE FITTING, GENERAL REQUIREMENTS FOR
Published by NPFC on October 2, 2013
This commercial item description (CID) covers the general requirements for conical seal, crush, 37 degree flared tube fitting. Requirements for conical seal, crush, 37 degree flared tube fitting are...
This document references:
QQ-A-1876 - ALUMINUM FOIL
Published by NPFC on July 29, 1974
This specification covers uncoated aluminum foil.
View Less
View All
Advertisement