UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

NPFC - AN 6204

VALVE, HYDRAULIC BLEEDER

active, Most Current
Buy Now
Organization: NPFC
Publication Date: 4 November 2013
Status: active
Page Count: 4

Document History

AN6204 REV L VALID NOTICE 2
July 24, 2023
Valve, Hydraulic Bleeder
A description is not available for this item.
AN 6204
August 6, 2018
Valve, Hydraulic Bleeder
A description is not available for this item.
AN 6204
November 4, 2013
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
AN 6204
December 5, 2012
Valve, Hydraulic Bleeder
A description is not available for this item.
AN 6204
May 25, 2006
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
AN 6204
January 25, 2006
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
AN 6204
November 10, 1999
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
AN 6204
February 22, 1988
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
AN6204 REV G
July 11, 1979
VALVE, HYDRAULIC BLEEDER
A description is not available for this item.
View Less
View All

References

This document references:
ASME B1.1 - Unified Inch Screw Threads (UN and UNR Thread Form)
Published by ASME on January 1, 2019
This Standard specifies the thread form, series, class, allowance, tolerance, and designation for unified screw threads. (In order to emphasize that unified screw threads are based on inch modules,...
This document references:
ASME B46.1 - Surface Texture (Surface Roughness, Waviness, and Lay)
Published by ASME on January 1, 2019
This Standard is concerned with the geometric irregularities of surfaces. It defines surface texture and its constituents: roughness, waviness, and lay. It also defines parameters for specifying...
This document references:
ASME Y14.5 - Dimensioning and Tolerancing
Published by ASME on January 1, 2018
INTRODUCTION This Standard establishes symbols, rules, definitions, requirements, defaults, and recommended practices for stating and interpreting dimensioning, tolerancing, and related requirements...
This document references:
A693 - Standard Specification for Precipitation-Hardening Stainless and Heat-Resisting Steel Plate, Sheet, and Strip
September 1, 2022
This specification2 covers precipitation-hardening stainless steel plate, sheet, and strip. The mechanical properties of these steels are developed by suitable low-temperature heat treatments...
This document references:
A705/A705M - Standard Specification for Age-Hardening Stainless Steel Forgings
May 1, 2023
This specification2 covers age-hardening stainless steel forgings for general use. The values stated in either SI units or inch-pound units are to be regarded separately as standard. The values...
This document is referenced by:
MIL-B-8584 - BRAKE SYSTEMS, WHEEL, AIRCRAFT DESIGN OF
Published by NPFC on August 12, 1970
This specification covers the brake system design requirements for aircraft equipped with wheel-type landing gear. The brake systems shall be either hydraulic or pneumatic; manually operated, power...
View Less
View All
Advertisement