GME 00005
General Requirements for Vacuum Metallised Plastic Components
inactive
Buy Now
| Organization: | GME |
| Publication Date: | 1 June 1979 |
| Status: | inactive |
| Page Count: | 14 |
scope:
1. 1.1 scope
This specification details the requirements for vacuum metallised finishes on plastic components used for interior and exterior applications on automobiles. This form of finish should only be used on surfaces not subjected to excessive wear and where the anticipated service temperature for the part does not normally exceed +85 degrees C.
Document History
November 1, 2012
General Requirements for Vacuum Metallised Plastic Components
This specification details the requirements for vacuum matallised finishes on plastic components used for interior and exterior applications on automobiles. This form of finish should only be used on...
GME 00005
June 1, 1979
General Requirements for Vacuum Metallised Plastic Components
1. 1.1 scope This specification details the requirements for vacuum metallised finishes on plastic components used for interior and exterior applications on automobiles. This form of finish should...