UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS EN ISO 3650

Geometrical Product Specifications (GPS) - Length Standards - Gauge Blocks

active, Most Current
Buy Now
Organization: BSI
Publication Date: 15 May 1999
Status: active
Page Count: 26
ICS Code (Measuring instruments): 17.040.30
ICS Code (Geometrical Product Specification (GPS)): 17.040.40

Document History

BS EN ISO 3650
May 15, 1999
Geometrical Product Specifications (GPS) - Length Standards - Gauge Blocks
A description is not available for this item.

References

This document references:
BS EN ISO 1 - Geometrical product specifications (GPS) - Standard reference temperature for the specification of geometrical and dimensional properties
Published by BSI on July 31, 2022
A description is not available for this item.
This document references:
BS EN ISO 1101 - Geometrical Product Specifications (GPS) — Geometrical tolerancing — Tolerances of form, orientation, location and run-out
Published by BSI on February 28, 2017
A description is not available for this item.
This document references:
BS EN ISO 14253-1 - Geometrical product specifications (GPS) - Inspection by measurement of workpieces and measuring equipment Part 1: Decision rules for verifying conformity or nonconformity with specifications
Published by BSI on February 28, 2018
A description is not available for this item.
This document references:
EN ISO 6507-1 - Metallic materials - Vickers hardness test - Part 1: Test method
Published by CEN on October 1, 2023
This document specifies the Vickers hardness test method for the three different ranges of test force for metallic materials, including hard metals and other cemented carbides, metallic coatings and...
This document is referenced by:
BS 1726-2 - Cylindrical helical springs made from round wire and bar - Guide to methods of specifying, tolerances and testing - Part 2: Extension springs
Published by BSI on September 25, 2002
A description is not available for this item.
This document is referenced by:
BS EN ISO 14253-2 - Geometrical product specifications (GPS) - Inspection by measurement of workpieces and measuring equipment Part 2: Guidance for the estimation of uncertainty in GPS measurement, in calibration of measuring equipment and in product verification
Published by BSI on May 31, 2011
A description is not available for this item.
This document is referenced by:
BS 1726-1 - Cylindrical helical springs made from round wire and bar - Guide to methods of specifying and tolerancing hot coiled springs, and cold coiled springs not covered by BS EN 15800, and general spring testing Part 1: Compression springs
Published by BSI on November 30, 2010
A description is not available for this item.
This document is referenced by:
BS EN ISO 14978 - Geometrical Product Specifications (GPS) - General concepts and requirements for GPS measuring equipment
Published by BSI on March 31, 2019
A description is not available for this item.
This document is referenced by:
BS 8726-1 - Cylindrical helical springs made from rectangular and square section wire and bar - Guide to calculation and design - Part 1: Compression springs
Published by BSI on September 25, 2002
A description is not available for this item.
View Less
View All

Related Products

Searching for related products...

Advertisement