UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

FORD M99C119-A

OIL, TRANSFORMER

active, Most Current
Buy Now
Organization: FORD
Publication Date: 1 September 1991
Status: active
Page Count: 1
scope:

1. SCOPE:

The Material desired under this standard is a refined mineral oil.

Document History

M99C119-A
September 1, 1991
OIL, TRANSFORMER
1. SCOPE: The Material desired under this standard is a refined mineral oil.
FORD M99C119-A
September 1, 1991
OIL, TRANSFORMER
1. SCOPE: The Material desired under this standard is a refined mineral oil.

References

This document references:
FORD MCX - CLAUSES, STANDARD, FOR USE IN MANUFACTURING STANDARDS
Published by FORD on September 1, 1987
This standard contains those paragraphs which are repetitively applied to the "M" category of Ford Manufacturing Standards.
This document references:
ASTM D1275 - Standard Test Method for Corrosive Sulfur in Electrical Insulating Liquids
Published by ASTM on November 15, 2015
This test method describes the detection of corrosive sulfur compounds (both inorganic and organic) in electrical insulating liquids. New and in-service insulating liquids may contain elemental...
This document references:
D445 - Standard Test Method for Kinematic Viscosity of Transparent and Opaque Liquids (and Calculation of Dynamic Viscosity)
November 1, 2023
This test method specifies a procedure for the determination of the kinematic viscosity, ν, of liquid petroleum products, both transparent and opaque, by measuring the time for a volume of liquid to...
This document references:
ASTM D877/D877M - Standard Test Method for Dielectric Breakdown Voltage of Insulating Liquids Using Disk Electrodes
Published by ASTM on December 1, 2019
This test method describes two procedures, A and B, for determining the electrical breakdown voltage of insulating liquid specimens. The breakdown test uses ac voltage in the power-frequency range...
This document references:
ASTM D92 - Standard Test Method for Flash and Fire Points by Cleveland Open Cup Tester
Published by ASTM on July 1, 2018
This test method describes the determination of the flash point and fire point of petroleum products by a manual Cleveland open cup apparatus or an automated Cleveland open cup apparatus. NOTE 1—The...
This document references:
D97 REV B - Standard Test Method for Pour Point of Petroleum Products
December 15, 2017
This test method covers and is intended for use on any petroleum product.3 A procedure suitable for black specimens, cylinder stock, and nondistillate fuel oil is described in 8.8. The cloud point...
View Less
View All
Advertisement