UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

IEEE 116

STANDARD TEST PROCEDURE FOR CARBON BRUSHES

inactive
Buy Now
Organization: IEEE
Publication Date: 27 February 1975
Status: inactive
Page Count: 11

Document History

IEEE 116
February 27, 1975
STANDARD TEST PROCEDURE FOR CARBON BRUSHES
A description is not available for this item.

References

This document is referenced by:
IEEE 286 - Recommended Practice for Measurement of Power Factor Tip-Up of Electric Machinery Stator Coil Insulation
Published by IEEE on March 30, 2000
Foreword This power factor tip-up test for stator coils has been used by electric machinery manufacturers and users since the original standard was issued in 1968. The original versions discussed...
This document is referenced by:
IEEE 325 - Standard Test Procedures for Germanium Gamma-Ray Detectors
Published by IEEE on October 18, 1996
This standard applies to germanium radiation detectors that are used for the detection and high-resolution spectrometry of gamma rays, X rays, and charged particles that produce hole-electron pairs...
Advertisement