Scope. This specification covers the requirements for headset-microphones with rigid headband. These parts meet established requirements for communications equipment used to protect against hazardous noise exposure and are approved for use in certain high and moderate ambient...
QUALIFIED PRODUCT LIST OF PRODUCTS QUALIFIED UNDER PERFORMANCE SPECIFICATION MIL-PRF-87819 Headset-Microphone, (Hearing Protective Type, High and Moderate Ambient Noise Levels), General Specification for This list has been prepared for use by or for the Government in the...
Headset-microphone PIN M87819/8 is a high ambient noise level headset-microphone designed for use by F-35 flight deck personnel to provide communication under the extreme noise conditions encountered in close proximity to F-35 and other fighter, transport, and tanker aircraft engines, on the flight...
Introduction The locally prevailing air temperature, the moisture content in the air (% relative humidity), and the temperature at which moisture will condense on surfaces (dew point) are commonly called the ambient conditions. If these conditions are not within the ranges required by a...
This standard specifies requirements and procedures for the measurement of sound pressure levels in building spaces or rooms. These requirements and procedures apply ideally to measurements performed in unoccupied spaces, with normal building services and HVAC equipment operating under...
Hearing measurements in an audiometric test room may be conducted for different audiometric purposes over different test frequency ranges. However, if the ambient noise level is excessively high, some hearing threshold levels measured in that environment will be...
1.1 This practice provides guidelines for acoustic emission (AE) examinations of seamless pressure vessels (tubes) of the type used for distribution or storage of industrial gases. 1.2 This practice requires pressurization to a level greater than normal use. Pressurization medium may be gas...
1.1 In harmony with the Joint Committee for Guides in Metrology (JCGM) and detection concepts of the International Union of Pure and Applied Chemistry (IUPAC) (1, 2), this test method uses a series of replicated measurements of an analyte at dosage levels giving instrumental responses that...
5.1 Concepts: 5.1.1 This guide summarizes the equipment, field procedures and interpretation methods used for the investigation of subsurface materials and geological structure as based on their properties to conduct, enhance or obstruct the flow of electrical currents induced in the ground by an...
1.1 This test method covers the field, or in situ measurement of sound power level by the two-surface method. The test method is designed to minimize the effects of reverberant conditions, directivity of the noise source under consideration, and the effects of ambient...
5.1 All noise control features associated with the inlet or exhaust of large industrial fans and gas turbines are, or should be, based upon inlet or exhaust sound power levels in octave bands of frequency. Sound power levels are not directly measurable, however, so they must be...
Narrow Your Results