The CABS Auxiliary Report Specifications (CARS) are guidelines for providing standard reports and/or standard mechanized file layouts, where appropriate. These standards will not be documented in the CABS Billing Output Specifications (BOS). The following guidelines apply to report outputs...
The CABS Auxiliary Report Specifications (CARS) are guidelines for providing standard reports and/or standard mechanized file layouts, where appropriate. These standards will not be documented in the CABS Billing Output Specifications (BOS). The following guidelines apply to report outputs...
1.1 This practice covers an updated procedure for evaluating corrosion protection and performance of an engine coolant in passenger car, light truck service that closely imitates current vehicle and engine manufacturers' practices. Note 1: Coolant evaluation in vehicle service may require...
4.1 Upon deployment, at the site of the vascular stenosis, the stent establishes the patency of the lumen until vascular remodeling occurs. The radial load acting upon the stent is imparted by vessel and lesion stretch. Additionally, the vessel might be affected by excursions due to pulsation...
1.1 This practice covers procedures for the sampling and data reporting of bulk shipments of carbon black in three-compartment hopper rail cars and compartmented bulk hopper trailers. Note 1: The tests to be made on the samples obtained by this practice, how many samples are taken, where...
1.1 This guide is intended for Part 23 and predecessor aircraft (see Civil Air Regulations (CAR) 3) and: 1.1.1 Is applicable to aircraft to which Part 43 applies. 1.1.2 Addresses both initial installation and replacement of aircraft articles. 1.1.3 Is a guide for classifying an alteration. 1...
1.1 These practices are intended to serve as a guide to shippers, carriers, and consignees for load planning, loading, blocking, and bracing of intermodal and unimodal cargo in surface transport. The practices are referenced to a bibliography of information concerning the above. Hazardous...
1.1 This practice describes a method to laboratory age a new tire in an oven to produce changes in certain chemical and physical properties at the belt edges similar to those of tires in-service (see Appendix X1). 1.2 This practice is a precursor to conducting an ASTM standard roadwheel test method...
5.1 This test method is intended to be used mainly as a means of comparing the performance of unitizing films. It can also be used to compare the effectiveness of different wrap cycles with the same wrapping materials. No direct correlation between these tests results and actual field performance...
1.1 This practice covers (1) a statistical procedure for analyzing the test data generated in the statistical process control of a carbon black manufacturing process; (2) a format for reporting process capability determined from the analysis of control chart data of an individual production run,...
Narrow Your Results