This specification establishes a color-coding system to identify the anticoagulants used in coating pipets or containers not exceeding 1 mL in volume. Its purpose is to ensure that if a color code is used with an anticoagulant, all manufacturers will be encouraged, though not...
4.1 Color of material rubber is of importance in compounds where product color is determined by the color of the raw rubber.
1.1 This specification covers dry-cast hollow and solid nonloadbearing concrete masonry units machine-made from hydraulic cement, water, and suitable mineral aggregates with or without the inclusion of other materials. These units are intended for use in nonloadbearing partitions, but under certain...
5.1 The results obtained with a mechanical muller do not necessarily correlate directly with an industrial situation where different dispersing conditions exist. However, dispersion with a mechanical muller is a quick and inexpensive way to prepare specimens for testing the color and...
1.1 This practice describes the equipment and operation of the Vettermann drum tester for testing pile yarn floor covering to produce changes in appearance and color due to changes in surface structure by mechanical action. 1.2 This practice is only applicable for use in testing unused pile...
This specification covers toluene diisocyanate used as an ingredient in the production of polyurethane cellular materials. The three classes of toluene diisocyanate covered in this specification are based on isomer ratio, and the three types are based on acidity and hydrolyzable chloride. Materials...
This specification covers polyester grade ethylene glycol. Sampled specimens shall undergo tests, for which the following chemical and physical requirements should be met: acidity (as acetic acid); aldehydes (acetaldehyde) content; appearance; chloride content; color (Pt-Co scale); glycols...
5.1 It is generally recognized that the best method for evaluating printing properties of ink-substrate combinations is by actual printing. this practice provides a convenient method for preparing repeatable laboratory prints at realistic conditions of printing speed, printing pressure and ink film...
5.1 Tannins and other chromophoric extractives are naturally occurring materials in wood and wood-based substrates. Tannins are prevalent to a high degree in cedar, redwood, oak, and to a lesser degree in white and yellow pine. Tannins are also present in varying amounts in wood composition...
5.1 Acceptance Testing-This method of testing fabrics resistance to pilling is not recommended for acceptance testing. If it is used for acceptance testing, it should be used with caution because interlaboratory data are not available. In some cases the purchaser or supplier may have to test a...
1.1 This guide covers the evaluation of the effect of dyestuff color transfer or color loss from dyed fabrics. It is designed as a laboratory screening test to aid in the formulation of detergent products or the comparison of two or more detergents. 1.2 There is no single assessment...
Narrow Your Results