5.1 This test method may be used for material development, characterization, design data generation, and quality control purposes. 5.2 This test method is specifically appropriate for determining the modulus of advanced ceramics that are elastic, homogeneous, and isotropic (1). 5.3 This test method...
This specification covers the standard for front wheel retention systems for all bicycles equipped with manually operated retention systems such as a quick release. This specification is only for bicycles equipped with manually operated retention systems, and does not apply to...
5.1 Operating experience of gas turbines and diesel engines has shown that some of the ash-forming substances present in a fuel can lead to high temperature corrosion, ash deposition, and fuel system fouling. Ash-forming materials may be in a fuel as oil-soluble metallo-organic compounds as...
1.1 This test method covers the determination of fatigue of tire cords in rubber due to compression or extension, or both, using a disc fatigue tester. The fatigue is measured as a loss in strength. 1.2 The values stated in either SI units or inch-pound units are to be regarded separately as...
Includes: This instruction covers the procedure for the routine maintenance of batteries - sealed and top up type - and associated battery charging equipment installed on A.C. & D.C. Electrified Lines. Excludes: -
Includes: This instruction covers the routine maintenance of 25 kV Auxiliary Transformers located at signal supply points (i.e. PSP, ASP, etc..). Excludes: Voltage Regulators (these are covered in NR/DIST C07a)
Includes: This instruction covers the routine inspection and maintenance of all 25 kV A.C. switching station buildings including brick buildings, metal clad cabins and Structure Mounted Outdoor Switchgear ancillary equipment enclosures. Excludes:
Narrow Your Results