1.1 These requirements cover equipment intended for use indoors in an automotive repair facility. Products covered by this standard are as indicated in 2. This equipment is intended to be installed and used in accordance with the National Electrical Code, ANSI/NFPA 70. 1.2 These requirements cover...
Connection details and installation recommendations for glulam in residential garage door framing
This SAE Standard is directed at the proper communication of the lift points on the vehicle frame or underbody to commercial service personnel for the purpose of raising passenger vehicles, light trucks, and vans completely off the shop floor. To this end, vehicle manufacturers are guided in the...
This Standard specifies requirements for the design, construction, and installation of garage doors and other large access doors in external walls of buildings. This Standard covers domestic doors for openings up to three metres in height and general purpose doors...
This International Standard establishes a vocabulary of terms related to, and the principles of construction of, openers and cleaners used in the textile industry in the preparation for spinning of cotton and other staple fibres.
This part of IEC 60335 deals with the safety of electric drives for garage doors for residential use that open and close in a vertical direction, the rated voltage of the drives being not more than 250 V for single-phase appliances and 480 V for other appliances. It also covers the...
The rules of this Code cover requirements for equipment used exclusively for the parking of automobiles in buildings or structures where, during the parking process, each automobile is moved either under its own power, or by means of a power-driven transfer device, onto and off an elevator,...
1.1 General This European Standard specifies the safety and performance requirements, except resistance to fire and smoke control characteristics, for industrial, commercial, garage doors and gates and barriers, intended for installation in areas in the reach of persons, and for which...
This clause of Part 1 is replaced by the following. This part of IEC 60335 deals with the safety of electric drives for garage doors for residential use that open and close in a vertical direction, the rated voltage of the drives being not more than 250 V for single-phase appliances...
This clause of Part 1 is replaced by the following. This part of IEC 60335 deals with the safety of electric drives for garage doors for residential use that open and close in a vertical direction, the rated voltage of the drives being not more than 250 V for single-phase appliances...
Narrow Your Results