5.1 The stress-strain properties of unvulcanized rubber (either in a compound or in the raw state) are important to certain processing operations in the rubber industry. These unvulcanized rubber properties are frequently referred to as "green strength." 5.2 Green strength is...
1.1 This specification covers chlorinated and chlorinated-brominat
1.1 This standard covers a test method that may be used to measure the transverse rupture strength of a compacted but unsintered (green) test specimen produced from lubricated or unlubricated metal powders or powder mixtures. 1.2 Green strength is measured by a quantitative laboratory...
5.1 This practice shall only be used on soils having infiltration rates ranging from 2.5 mm/h (field hydraulic conductivity of 6.9?×?10-7 m/s) to 15000 mm/h (field hydraulic conductivity of 4.0?×?10-3 m/s). 5.2 This practice is useful for field measurement of the infiltration rate and calculation...
1.1 This practice is intended to assist the subcommittees and sections of Committee D20 on Plastics with the process of standards evaluation during the five-year review mandated by ASTM or when changes to test methods and specifications are required. It is intended to complement the Form and Style...
This specification covers particulate glass (cullet material) recovered from waste destined for disposal, smaller than 6 mm intended for reuse as a raw material in the manufacture of glass containers. Flint glass cullet is a particulate glass material that contains no more than 0.1 weight % Fe2O3,...
5.1 This section elaborates how the GMPC may be used in the context of the two main approaches to managing the execution of transportation mentioned in 4.8. These elaborations do not go into every possible detail of these approaches. The purpose of the elaborations is to provide an outline of the...
5.1 This section elaborates how the GMPC may be used in the context of the two main approaches to managing the execution of transportation mentioned in 5.2. These elaborations do not go into every possible detail of these approaches. The purpose of the elaborations is to provide an outline of the...
5.1 Nuclear grade graphite is a composite material made from petroleum or a coal-tar-based coke and a pitch binder. Manufacturing graphite is an iterative process of baking and pitch impregnation of a formed billet prior to final graphitization, which occurs at temperatures greater than 2500?°C....
4.1 These test methods can be used for determining which EPDM polymers are evaluated in the different compounds in Test Methods D3568. 4.2 Differences in ethylene sequence distribution cause differences in crystallinity and green strength at the same ethylene content. Since these are...
1.1 This classification covers the determination of commercially available natural muscovite block mica and is intended to be independent of the basic color of the mica or its source. 1.2 Muscovite mica is characterized by having an optical axial angle between 50 and 75° (see Appendix X1); and has...
1.1 This guide provides guidance and considerations related to designing sustainable low-sloped roofing systems, including exposed membrane roofs, membranes covered with landscaped and vegetative (green) overburden systems, ballasted roofs, and protected membrane roofing assemblies. A...
4.1 This guide provides the general information, procedures, and guidelines for the selection of the waterproofing membrane to create a waterproofing system for a vegetative (green) roof. 4.2 This guide is not all inclusive; this guide is intended to supplement detailed instructions from...
4.1 Several industry-developed standards and specifications exist, or are being developed for characterizing building products, based on a range of environmental and social threshold criteria for products throughout different life-cycle stages of production, construction, use, and end of life....
1.1 This practice is intended to assist the subcommittees and sections of Committee D20 on Plastics with the process of standards evaluation during the five-year review mandated by ASTM or when changes to test methods and specifications are required. It is intended to complement the Form and Style...
Narrow Your Results