PERSPECTIVE This report documents a study of earthquake design criteria for the eastern Gulf of Alaska. This study backgrounded a portion of the development of the Ninth Edition of API RP 2A's Section 2.10 earthquake design guideline effective ground acceleration and response spectra. This...
This standards publication applies to ground rod electrodes and ground rod electrode couplings that function in accordance with the National Electrical Code® (NFPA 70-2014) and/or the National Electrical Safety Code (ANSI C2-2012). Included are materials, construction,...
1.1 This specification covers hot- or cold-worked hafnium rod and wire. 1.2 This specification contains two material grades, one specifically for nuclear applications (Grade R1) and one for commercial alloying applications (Grade R3). 1.3 The products covered include the following: 1.3.1...
1.1 This specification2 covers rod of nickel-molybdenum alloys (UNS N10001, N10665, N10675, N10629, and N10624)3 as shown in Table 1, for use in general corrosive service. 1.2 The following products are covered under this specification: 1.2.1 Rods 5/16 in. to 3/4 in. (7.94?mm to 19.05...
4.1 Environmental site characterization projects almost always require information regarding subsurface soil stratigraphy and hydraulic parameters related to groundwater flow rate and direction. Soil stratigraphy often is determined by various drilling procedures and interpreting the data collected...
This standard covers zinc-coated ferrous ground rods used in overhead or underground line construction, or both.
1.1 This specification covers the chemical, mechanical, and metallurgical requirements for wrought cobalt-20chromium-15
1.1 This specification2 covers rod and bar of low-carbon nickel-chromium-moly
5.1 The direct push ground method is a rapid and economical procedure for installing groundwater monitoring wells to obtain representative groundwater samples and location-specific hydrogeologic measurements. Direct push installations may offer an advantage over conventional rotary drilled...
This specification covers nickel-chromium-iron
1.1 This test method covers the measurement of a longitudinal profile of a travelled surface using a static level for the purpose of obtaining a road roughness index. This test method is suitable for all surface types that are travelled by conventional ground vehicles, including paved and...
1.1 This test method covers the measurement of the penetration rate of the dynamic cone penetrometer with an 8 kg [17.6 lb] hammer (8 kg [17.6 lb] DCP) through undisturbed soil or compacted materials, or both. The penetration rate may be related to in situ strength such as an estimated in situ CBR...
1.1 This specification covers four grades of wrought zirconium and zirconium alloy bars, rod, and wire as follows: 1.1.1 R60001-Unalloyed grade, 1.1.2 R60802-Zirconium-Tin
1.1 This specification covers the chemical, mechanical, and metallurgical requirements for wrought cobalt-20chromium-15
This specification covers a titanium alloy in the form of bars and rods 1.00 inch (25.4 mm) and under in nominal diameter.
1.1 This specification covers finished sintered and ground (U, Pu)O2 pellets for use in light water reactors. It applies to (U, Pu)O2 pellets containing a plutonium mass fraction up to 15?% (that is, mass of Pu divided by the sum of masses U, Pu, and Am yielding 0.15 or less). 1.2 Pellets...
Narrow Your Results