This part of ISO 16635 specifies requirements and test methods for hole punches for dental rubber dam.
This part of ISO 16635 specifies requirements and test methods for hole punches for dental rubber dam.
This part of ISO 16635 specifies requirements and test methods for hole punches for dental rubber dam.
1.1 This test method describes the procedures for measuring the water mass per unit volume of soil and soil-aggregate by use of an in situ permittivity probe. Measurements are taken at a depth beneath the surface of the soil determined by the design of the probe. 1.1.1 For limitations see Section 6...
This specification establishes allowable burr heights on primary (Class"A") and secondary surfaces and covers diametrical tolerances for four (4) classes of holes. Class 0 - Reamed Holes Class 1 - Drilled Holes Class 2 - Punched Holes Class 3 - Non-critical...
5.1 Plastics are viscoelastic and it is possible that they are sensitive to changes in velocity of weights falling on their surfaces. However, the velocity of a free-falling object is a function of the square root of the drop height. A change of a factor of two in the drop height will cause a...
1.1 This test method presents a direct, measurement of the dispersibility and consequent colloidal erodibility of clay soils by causing water to flow through a small hole punched in a specimen. The results of the tests are qualitative and provide general guidance regarding...
This standard specifies the size and location of rectangular holes in twelve-row 3%-inch wide punched cards. To be a processable document, suitable for information interchange. cards must also meet USA Standard Specifications for General Purpose Paper Cards for Information Processing,...
Specifies the dimensions and location of punched holes in paper tape and discusses environmental conditions for punching and reading.
This specification covers corrugated steel structural plate, zinc-coated, used in the construction of pipe, pipe-arches, arches, underpasses, and special shapes for field assembly. Appropriate fasteners and accessory materials are also described. The pipe, arches, and other shapes are generally...
Introduction Note: Nothing in this standard supercedes applicable laws and regulations. Note: In the event of conflict between the English and domestic language, the English language shall take precedence. Purpose. This standard provides acceptance criteria for nuts clinched with or without...
This standard specifies guideline values for hole diameters of thread rolling screws complying with DIN 7500-1 and DIN 267-30. These hole diameters are the result of practical tests carried out by manufacturers and users. The values given are intended for guidance and they are...
Introduction Note: Nothing in this standard supercedes applicable laws and regulations. Note: In the event of conflict between the English and domestic language, the English language shall take precedence. Purpose. This specification provides the acceptance criteria for product joined by...
This specification covers corrugated steel structural plate, zinc-coated, used in the construction of pipe, pipe-arches, arches, underpasses, and special shapes for field assembly. Appropriate fasteners and accessory materials are also described. The pipe, arches, and other shapes are generally...