1.1 This practice describes procedures for specimen preparation and mounting when testing pipe and duct insulation materials to assess flame spread and smoke development as surface burning characteristics using Test Method E84. 1.2 If the pipe or duct insulation...
5.1 Some insulation materials contain moisture, which will affect the thermal and other physical properties of the insulation.
6.1 This test method provides a means of measuring the water absorption of flat or cylindrical specimens of thermal insulation materials under isothermal conditions as a result of direct immersion in liquid water. It is intended for quality control and product and material...
1.1 This practice describes procedures for specimen preparation and mounting when testing pipe and duct insulation materials to assess flame spread and smoke development as surface burning characteristics using Test Method E84. 1.2 If the pipe or duct insulation...
1.1 This classification identifies potential concerns and effects that could result from direct contact with thermal insulation materials and accessories, or be caused by indirect action of events such as aging, fire, or physical disturbance. 1.2 Intent of Classification: 1.2.1 It is...
2.1 The type of materials used in the manufacture of insulation products and the type of membrane used to face these products can sometimes affect fungi sustenance in the presence of high humidity. 2.2 This test method is used to determine the relative ability of an insulation...
1.1 This practice is intended to provide guidance and direction in the handling, transporting, shipping, storage, receiving, and application of thermal insulating materials to be used as a surface treatment or as part of the thermal insulation system in contact with austenitic...
1.1 This standard covers a test method for measurement of thermal impedance and calculation of an apparent thermal conductivity for thermally conductive electrical insulation materials ranging from liquid compounds to hard solid materials. 1.2 The term "thermal conductivity"...
Note: Nothing in this standard supercedes applicable laws and regulations. Note: In the event of conflict between the English and domestic language, the English language shall take precedence. Purpose/Material Description. Materials shall be identified by Types (see Table 1) according...
5.1 This practice is intended to measure air flow through materials used to fill joints found in building construction. 5.2 This practice does not purport to establish all required criteria for the selection of an air barrier assembly. Therefore, the results should be used only for...
4.1 Thermal insulating materials that produce objectionable odors could cause discomfort to persons occupying a structure insulated with such materials. Therefore, an examination to determine the odor potential of a particular insulation is desirable.
This specification addresses the physical, chemical and test requirements for structural insulated panel (SIP) adhesives suitable for the bonding of oriented strand boards (OSB) to rigid cellular polystyrene thermal insulation core materials for general structural use. Douglas-fir to...
18.1 This test method provides useful engineering information for evaluating the mechanical behavior of rigid electrical insulation at elevated temperature. When the proper exposure and test temperatures are chosen, depending on the material and end-use operating temperature, use the...
2.1 The type of materials used in the manufacture of insulation products and the type of membrane used to face these products can sometimes affect fungi sustenance in the presence of high humidity. 2.2 This test method is used to determine the relative ability of an insulation...
1.1 These test methods cover laboratory procedures for the determination of water-leachable chloride, fluoride, silicate, and sodium ions in thermal insulation materials in the parts per million range. 1.2 Selection of one of the test methods listed for each of the ionic...
This Practice provides requirements for materials and installation of hot service insulation systems on the external surfaces of piping and equipment, ambient to 649°C (1200°F). This Practice describes requirements for hot service insulation materials and accessories,...
4.1 Two fire test methods are contained in this standard. Both test methods provide procedures which make relative comparisons of the ignitability and continued flaming (if ignition occurs) of the rigid electrical insulation materials being tested after the application of an ignition...
This Japanese Industrial Standard specifies inorganic porous thermal insulation boards (hereafter referred to as "board insulation") and inorganic porous thermal insulation pipes (hereafter referred to as "pipe insulation") used for thermal insulation...
Narrow Your Results