loading
AIHA JOURNAL - THE AIHA JOURNAL 10-YEAR INDEX
AIHA
A description is not available for this item.
IEEE JOURNAL MICROELECTRO - IEEE JOURNAL - MICROELECTROMECHANICAL SYSTEMS
IEEE
A description is not available for this item.
IEEE JOURNAL COMM-TRANS - IEEE JOURNAL - COMMUNICATIONS - TRANSACTIONS
IEEE
A description is not available for this item.
IEEE JOURNAL SPECTRUM - IEEE JOURNAL - SPECTRUM (SPEC)
IEEE
A description is not available for this item.
IEEE JOURNAL ELECTRICAL - IEEE JOURNAL - ELECTRICAL INSULATION MAGAZINE
IEEE
A description is not available for this item.
IEEE JOURNAL SIGNAL-TRANS - IEEE JOURNAL - SIGNAL PROCESSING - TRANSACTIONS
IEEE
A description is not available for this item.
IEEE JOURNAL SIGNAL-MAG - IEEE JOURNAL - SIGNAL PROCESSING - MAGAZINE
IEEE
A description is not available for this item.
IEEE JOURNAL ANTENNAS-MAG - IEEE JOURNAL - ANTENNAS AND PROPAGATION - MAGAZINE
IEEE
A description is not available for this item.
IEEE JOURNAL VEHICULAR - IEEE JOURNAL - VEHICULAR TECHNOLOGY, TRANS. ON (VT)
IEEE
A description is not available for this item.
IEEE JOURNAL PERSONAL - IEEE JOURNAL - PERSONAL COMMMUNCATIONS MAGAZINE (M-PC)
IEEE
A description is not available for this item.
IEEE JOURNAL ELECTRON - IEEE JOURNAL - TRANSACTIONS ON ELECTRON DEVICES
IEEE
A description is not available for this item.
ASTM A986/A986M-01(2026) - Standard Specification for Magnetic Particle Examination of Continuous Grain Flow Crankshaft Forgings
February 1, 2026 - ASTM International

This test method covers the procedures for the standard practice of performing magnetic particle examination of continuous grain flow crankshaft forgings intended for medium speed diesel engines. Crankshafts shall be divided into four zones of decreasing operational stress, each of which have been...

ASTM F3427-25 - Standard Practice for Documenting Environmental Conditions for Utilization with Exoskeleton Test Methods
November 1, 2025 - ASTM International

4.1 This section provides a description of the environmental conditions listed in Section 1 and describes the sub-conditions within each condition. Examples provided for many of the conditions and sub-conditions are provided as guidance only. Each of the conditions described should be evaluated and...

ASTM E2907/E2907M-25 - Standard Practice for Examination of Paper Machine Rolls Using Acoustic Emission from Crack Face Rubbing
September 1, 2025 - ASTM International

1.1 This practice covers guidelines for acoustic emission (AE) examinations of non-pressure, paper machine rolls. 1.2 This practice utilizes a slow rotation of the roll to produce a full load cycle where load is provided by the weight of the roll suspended from its bearings or other journal...

ASTM E3424-25 - Standard Guide for Development and Validation Considerations of Advanced Process Control (APC) in Commercial Pharmaceutical Manufacturing
May 1, 2025 - ASTM International

5.1 APC is the foundation to smart manufacturing. Smart manufacturing has emerged as one key concept as the industry transitions to an Industry 4.0 paradigm. FDA has also recognized this industry trend and published a perspective paper on Industry 4.0 in the International Journal of...

ASTM D8279-25 - Standard Test Method for Determination of Timing-Chain Wear in a Turbocharged, Direct-Injection, Spark-Ignition, Four-Cylinder Engine
July 1, 2025 - ASTM International

1.1 Undesirable timing-chain wear has been observed with gasoline, turbocharged, direct-injection (GTDI) engines in field service, and data from correlating laboratory engine tests have shown that chain wear can be affected by appropriately formulated engine lubricating. A laboratory engine test...

Advertisement