This document establishes an adequate procedure to determine crosstalk values in order to improve comparability of measurement results between testing laboratories and to enable a load cell performance rating in accordance to the crosstalk specification for transducers in vehicle...
This practice covers the calibration of the reference load cell that is used for calibration of a Falling Weight Deflectometer (FWD) in R 32. It is used to establish calibration coefficients for the reference load cell. This procedure has been automated in a software...
This standard practice covers the annual calibration of the load cell and the deflection sensors and monthly relative calibration of the deflection sensors of a falling weight deflectometer (FWD) or a heavy weight deflectometer (HWD). It is used to establish calibration factors for...
1.1 This practice covers a split-force measurement apparatus (SFMA), a measurement system that uses split geometries and load cells to quantify the force of a grasp and external forces applied to an object under grasp. The SFMA supports a series of standard performance test methods...
5.1 Components of implanted medical devices can release ions, which may lead to adverse biological effects if released in sufficient quantities. Therefore, it may be necessary to characterize the ion release behavior over time to verify that a medical device or device components or both will not...
1.1 These test methods cover the determination of the resistance of plastics to "standardized" (see Note 1) pendulum-type hammers, mounted in "standardized" machines, in breaking standard specimens with one pendulum swing (see Note 2). The standard tests for these test methods require specimens...
1.1 This test method covers the measurement of the transmission of a gas through plastic membranes, sheeting, films, and fabric materials using a static sealed diffusion chamber. The test method monitors gas diffusion across a film membrane and provides measurements of (1) gas concentrations on...
5.1 In-plane shear loading tests on flat sandwich constructions may be conducted to determine the sandwich panel in-plane shear stiffness, the face sheets' in-plane strength, the core shear instability strength, or panel buckling response. 5.2 This test method can be used to produce face...
5.1 This section elaborates how the GMPC may be used in the context of the two main approaches to managing the execution of transportation mentioned in 4.8. These elaborations do not go into every possible detail of these approaches. The purpose of the elaborations is to provide an outline of the...
1.1 This test method covers the determination of compressive properties of flexible cellular materials during compressive loading and unloading at a uniform rate. 1.2 This test method is applicable to open- or closed-cell materials made from expanded synthetic or non-synthetic...
1.1 This practice covers a split-force measurement apparatus (SFMA), a measurement system that uses split geometries and load cells to quantify the force of a grasp and external forces applied to an object under grasp. The SFMA supports a series of standard performance test methods...
PURPOSE OF THIS BOOK It is the intent of this committee that the publication of this book will continue to progress a more uniform application of practices for the computation of design wind loads for petrochemical and industrial facilities. To facilitate this goal, a set of recommended...
Narrow Your Results