The provisions of the "Residential Code of Ohio for One-, Two-, and Three-Family Dwellings" shall apply to the construction, alteration, movement, enlargement, replacement, repair, equipment, use and occupancy, location, maintenance, removal, and demolition of every one-, two-, or...
This paper presents a gear design optimization approach that was applied to reduce both tooth contact temperature and noise excitation of a highspeed spur gear pair running without lubricant. The optimum gear design search was done using the RMC (Run Many Cases) program from The Ohio State...
This book contains papers presented in various technical sessions at the Polyurethanes Expo 2001 conference held between September 30-October 3, 2001 at Greater Columbus Convention Center, Columbus, Ohio. Author: Api Api
INTRODUCTION System Development Corporation (SDC) has performed a study to survey the characteristic use patterns of privately operated automobiles in the Cincinnati, Ohio urban area. The study was conducted under jointly sponsored research contracts to the National Center for Air...
This Practice provides supplier with requirements for all material, fabrication, finishes, and delivery of standard steel doors and frames. This Practice applies recommendations of the Steel Door Institute (SDI) of Westlake, Ohio. Comment: It is recommended that SDI-108 be used to prepare...
This Practice provides constructor with requirements for installing standard steel doors, frames and related hardware. It applies recommendations of the Steel Door Institute (SDI) of Westlake, Ohio and the Door and Hardware Institute (DHI) of Chantilly, Virginia. This Practice does not...
This book contains papers on algebra, functional analysis, and general topology, with a strong interaction with set theoretic axioms and involvement with category theory, presented in the special session on Rings of Continuous Functions held in 1982 in Cincinnati, Ohio. Author: Aull
INTRODUCTION System Development Corporation (SDC) has performed a study to survey the characteristic use patterns of privately operated automobiles in the Chicago, Illinois urban area. The study was conducted under jointly sponsored research contracts to the National Center for Air Pollution...
The influence of additional dynamic loads on the distributions of load, flank pressure and tooth root stress are shown. The additional dynamic loads excited by the variations of mesh stiffness and influenced by tooth deviations and modifications are calculated and used as input for the calculation...
A selection of articles presented at the Eighth Lukacs Symposium held at the Bowling Green State University, Ohio. They discuss consistency and accuracy of the sequential bootstrap, hypothesis testing, geometry in multivariate analysis, the classical extreme value model, the analysis of...
Proceedings of the 9th International Conference, Cleveland, Ohio, USA. Subject areas: ultrahard coatings; surface treatment and alternative processes; corrosion resistant coatings; characterisation of coatings; surface engineering of powders; laser processing; vapour deposition and plasma...
The material in this book is based upon a two-day workshop on solid state physical sensors for biomedical applications held in Huron, Ohio, December 8-9, 1977. The individual sections of the book are based upon presentations made by the authors at the workshop. Each presentation was...
PREFACE This publication represents a basic standard for the substantial and durable construction and acceptable performance of mechanically actuated automatic vent damper devices which are capable of being installed on existing gas-fired appliances and is predicated on the use of these devices...
"Based on the International Conference on Optimal Control of Differential Equations held recently at Ohio University, Athens, this Festschrift to honor the sixty-fifth birthday of Constantin Corduneanu an outstanding researcher in differential and integral equations provides in-depth...
1.1 This practice covers the mathematical processing of longitudinal profile measurements made by equipment that operates at traffic speeds to produce an estimate of subjective ride quality, termed Ride Number (RN). 1.2 The intent of this practice is to provide the highway community a...
Narrow Your Results