This Practice describes the electrical requirements for design, manufacture, inspection, testing, and shipping of packaged equipment (also referred to as skid mounted equipment). Electrical systems for packaged equipment can include components such as electrical...
This Practice describes the requirements and provides data sheets for the specification, procurement, fabrication, inspection, and testing of instrumentation, control and associated systems provided as applicable to "packaged equipment" as generally defined in Section 3 of this...
This Practice provides the minimum requirements for the performance, design, fabrication, testing, and inspection of instrumentation and control systems installed on small, general purpose packaged equipment units. This Practice is not intended for packaged analyzers systems or...
This Practice provides the minimum requirements for mechanical design and manufacturing of skid-mounted packaged equipment. Skid-mounted units are self-contained units consisting of equipment, their auxiliary systems, interconnecting piping, electrical and instrument...
4.1 The uranium hexfluoride (UF6), as described in Specifications C787 and C996, has to meet different requirements: one set of requirements being safety, health physics, and criticality and the other set being chemical, physical, and isotopic. To ensure the UF6 is in compliance with all...
This Practice provides the purchaser with the method for preparing PIP PCDPS001-R, Packaged Equipment Instrumentation Documentation Requirements Sheet. Packaged equipment suppliers should also become familiar with the symbology used. This Practice contains key...
1.1 This standard specifies minimum performance requirements and test methods for the ballistic resistance of shields used by U.S. law enforcement officers to protect against handgun and rifle ammunition. 1.1.1 The option for testing either handgun-rated or rifle-rated shields with a shotgun threat...
1.1 This practice describes standardized procedures for the preparation, spraying, packaging, and shipping of fresh spray polyurethane foam (SPF) insulation product samples to be tested for their emissions of volatile organic compounds (VOCs) and semi-volatile organic compounds (SVOCs)....
1.1 These test methods explain the procedure for determining the ability of packages to withstand internal pressurization. 1.2 The burst test increasingly pressurizes the package until the package fails. 1.3 The creep test maintains a specified pressure for a specified time or...
5.1 There is interest from industry and CAAs to create a means of compliance for software assurance for UAS, particularly in instances where conventional design assurance requirement management processes may over-prescribe requirements in relation to the level of risk of the UAS operation, or of...
These specifications and test methods provide standard specifications that specify material, labeling, and handling requirements for components used in surgical fixation of the spinal skeletal system such as metallic spinal screws, spinal plates, and spinal rods. The specifications and test methods...
5.1 This test method covers the rapid determination of 22 elements in used and unused lubricating oils and base oils, and it provides rapid screening of used oils for indications of wear. Test times approximate a few minutes per test specimen, and detectability for most elements is in the low mg/kg...
The scope of this document is related to the particular needs of oxygen equipment with regards to packaging and transportation. The document provides guidance for handling chemical, gaseous and liquid oxygen equipment. It summarizes national and international regulations to be...
6.1 Seal and material surface integrity attributes may be linked to a number of variables in process parameters, equipment, or material, as well as environmental (room temperature and relative humidity). Visual characteristics of suspect integrity defects in primary packaging,...
1.1 This guide provides information to clarify the process of validating packaging test methods specific for an organization utilizing them as well as through inter-laboratory studies (ILS), addressing consensus standards with inter-laboratory studies (ILS) and methods specific to an...
1.1 This guide covers information on selection of insulation materials, systems design, application methods, protective coverings, guarantees, inspection, testing, and maintenance of thermal insulation primarily for industrial applications in a temperature range of -320 to 1200°F (-195.5 to 648...
1.1 These practices cover the collection of visible powders that are suspected biological agents and toxins from solid nonporous surfaces using a bulk collection method, using a dry swab and laminated card, followed by a swab sampling method using a sterile moistened swab. Bulk powder samples are...
Narrow Your Results