This standard describes the composition, performance requirements, construction practices and workmanship, design, and methods of testing thermosetting fiberglass-reinforce
Purpose. This specification covers the material requirements for blow moldable plastic fuel tanks. Component testing and full vehicle system validation is required prior to material approval.
This standard is applied only to gasoline all the models of sedan and van. PURPOSE This standard is to define the general requirements for plastic fuel tank.
1.1 This practice covers acoustic emission (AE) examination or monitoring of fiberglass-reinforce
General This specification covers material, design, fabrication, and testing requirements for fiberglass-reinforce
What is included This Publication is aimed at owners and operators of above-ground plastic tanks, which are typically cylindrical in shape. The document's content is aimed mainly at tanks being operated at atmospheric pressure or at pressures above the liquid head up to 0.5...
4.1 When choosing a thermal insulation product or combination of products, physical, chemical and mechanical properties and the significance of those properties should be considered. ASTM test methods are usually performed under laboratory conditions and may not accurately represent field...
1.1 This practice covers guidelines for acoustic emission (AE) examinations of pressurized containers made of fiberglass reinforced plastic (FRP) with balsa cores. Containers of this type are commonly used on tank trailers for the transport of hazardous chemicals. 1.2 This practice is...
5.1 Concepts: 5.1.1 This guide summarizes the equipment, field procedures and interpretation methods used for the investigation of subsurface materials and geological structure as based on their properties to conduct, enhance or obstruct the flow of electrical currents induced in the ground by an...
This specification covers the requirements for extruded (cast or blown) and compression-molded sheeting made from low-, medium-, and high-density polyethylenes and copolymers in specified thicknesses. Depending on the functional requirements, sheeting conforming to this specification is used in...
1.Scope This specification covers the properties for coextruded multi-layer blow moldable plastic fuel tank, to meet enhanced EVAP regulation.
5.1 Direct Push Soil Sampling is used extensively in environmental site characterization of soils below ground surface and can also be used for subsurface geotechnical site characterization (3, 7-13). Limited early studies have been done using Direct Push Soil Sampling for environmental...
This standard applies to HDPE (High Density Poly Ethylene), raw material for plastic fuel tank. PURPOSE This standard aims at specifying the test method for the resistance to detergent under stress-cracking of HDPE, raw material for plastic fuel tank.
5.1 Shearography is commonly used during product process design and optimization, process control, after manufacture inspection, and in service inspection, and can be used to measure static and dynamic axial (tensile and compressive) strain, as well as shearing, Poisson, bending, and torsional...
4.1 Perfluoroalkyl and polyfluoroalkyl substances (PFAS) are a family of more than 4700 synthetic organic chemicals. PFAS can withstand high temperatures and survive highly corrosive environments. They are used in the manufacture of coatings, surface treatments, and specialty chemicals in cookware,...
Narrow Your Results