loading
PCMCIA SYSTEM - PCMCIA SYSTEM ARCHITECTURE
PCMCIA
A description is not available for this item.
IEEE INFORMATION - INFORMATION GRAPHICS: A COMPRHENSIVE ILLUSTRATED REFERENCE
IEEE
A description is not available for this item.
ASHRAE SYSTEMS & EQUIP SI - 2020 ASHRAE Handbook HVAC Systems and Equipment SI Edition
January 1, 2020 - ASHRAE
A description is not available for this item.
ASHRAE SYSTEMS & EQUIP IP - 2020 ASHRAE Handbook HVAC Systems and Equipment I-P Edition
January 1, 2020 - ASHRAE
A description is not available for this item.
MPIF SINTERING DENSIFICAT - Sintering Densification, Grain Growth & Microstructure
January 1, 2005 - MPIF
A description is not available for this item.
IEEE INFORMATION THEORY: - INFORMATION THEROY: 50 YEARS OF DISCOVERY
IEEE
A description is not available for this item.
ASTM B312-25 - Standard Test Method for Green Strength of Specimens Compacted from Metal Powders
September 1, 2025 - ASTM International

1.1 This standard covers a test method that may be used to measure the transverse rupture strength of a compacted but unsintered (green) test specimen produced from lubricated or unlubricated metal powders or powder mixtures. 1.2 Green strength is measured by a quantitative laboratory procedure in...

ASTM E2534-20(2025) - Standard Practice for Targeted Defect Detection Using Process Compensated Resonance Testing Via Swept Sine Input for Metallic and Non-Metallic Parts
June 1, 2025 - ASTM International

1.1 This practice describes a general procedure for using the process compensated resonance testing (PCRT) via swept sine input method for metallic or non-metallic parts to compare resonance patterns from a sample under test to reference teaching sets of known acceptable and targeted defect samples...

ASTM B783-24 - Standard Specification for Materials for Ferrous Powder Metallurgy (PM) Structural Parts
October 1, 2024 - ASTM International

This specification covers a variety of ferrous powder metallurgy structural materials and includes a classification system or material designation code. The classification system includes chemical composition, minimum offset yield strength for as-sintered materials, minimum...

ASTM C1862-17(2025) - Standard Test Method for the Nominal Joint Strength of End-Plug Joints in Advanced Ceramic Tubes at Ambient and Elevated Temperatures
January 1, 2025 - ASTM International

1.1 This test method covers the determination of the push-out force, nominal joint strength, and nominal burst pressure of bonded ceramic end-plugs in advanced ceramic cylindrical tubes (monolithic and composite) at ambient and elevated temperatures (see 4.2). The test method is broad in scope and...

ASTM A1071/A1071M-11(2023) - Standard Test Method for Evaluating Hygrothermal Corrosion Resistance of Permanent Magnet Alloys
December 1, 2023 - ASTM International

5.1 This test method provides a controlled corrosive environment which can be utilized to produce relative corrosion resistance information for sintered permanent magnets. 5.2 Although prediction of performance in natural environments has seldom been statistically correlated with...

ASTM C331/C331M-23 - Standard Specification for Lightweight Aggregates for Concrete Masonry Units
June 1, 2023 - ASTM International

1.1 This specification covers lightweight aggregates intended for use in concrete masonry units when a prime consideration is to reduce the density of the units. 1.2 The values stated in either SI units or inch-pound units are to be regarded separately as standard. The values stated in each...

JIS INFORMATION SECURITY - JIS Information Security/LAN/Bar Code/RFID Handbook
January 1, 2019 - JSA
A description is not available for this item.
Advertisement