UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS 1134

Assessment of surface texture - Guidance and general information

active, Most Current
Buy Now
Organization: BSI
Publication Date: 31 December 2010
Status: active
Page Count: 60
ICS Code (Properties of surfaces): 17.040.20

Document History

BS 1134
December 31, 2010
Assessment of surface texture - Guidance and general information
A description is not available for this item.

References

This document references:
BS EN ISO 9000 - Quality management systems - Fundamentals and vocabulary
Published by BSI on September 30, 2015
A description is not available for this item.
This document references:
BS EN ISO 12179 - Geometrical Product Specifications (GPS) - Surface texture: Profile method - Calibration of contact (stylus) instruments
Published by BSI on August 22, 2001
A description is not available for this item.
This document references:
BS EN ISO 12085 - Geometric Product Specification (GPS) - Surface texture: Profile method - Motif parameters
Published by BSI on July 31, 2009
A description is not available for this item.
This document is referenced by:
BS 3821-2 - Hardmetal dies and associated hardmetal tools Part 2: As-sintered pellets and finished dies for drawing round wire
Published by BSI on July 29, 1974
Shows the dimensions of as-sintered pellets and finished hardmetal dies and certain quality aspects of finished dies for drawing ferrous and non-ferrous round wire. The dies are intended to produce...
This document is referenced by:
BS 2A 241 - General requirements for steel protruding-head bolts of tensile strength 1250 MPa (180 000 lbf/in2) or greater - Specification
Published by BSI on May 18, 2005
A description is not available for this item.
This document is referenced by:
BS 3821-3 - Hardmetal Dies and Associated Hardmetal Tools Part 3: As-Sintered Pellets and Finished Dies for Drawing Round Bar
Published by BSI on July 29, 1974
Specifies dimensions of as-sintered pellets and finished dies for drawing round bar from steel in the range 9 mm to 61 mm diameter and from non-ferrous metal in the range 9 mm to 73 mm diameter.
This document is referenced by:
BS 2573-2 - Rules for the Design of Cranes - Part 2: Specification for classification, stress calculations and design of mechanisms
Published by BSI on December 31, 1980
Classification of mechanisms for all types of cranes based on severity of intended use, loads and load combinations, calculation of stresses, stresses in components and the selection and verification...
This document is referenced by:
DEF STAN 02-835 - Requirements for High Strength Copper Nickel Manganese Alloy Forgings, Forging Stock Rods and Sections
Published by MODUK on September 28, 2018
This Def Stan relates to the requirements for the manufacture, inspection and testing of high strength copper-nickel-manganese forgings, forging stock, rods and sections. Forgings are placed in four...
View Less
View All

Related Products

Searching for related products...

Advertisement