This document references:
NR/L3/TRK/002 - Track Maintenance Handbook
Published by NR
on
June 4, 2011
The TMH shall be used by all Track / Off Track Engineering and Maintenance staff undertaking Patrolling, Inspection, Maintenance of Track/Off Track assets. Use of the TMH will establish a consistent...
This document references:
NR/SP/CTM/011 - Competence & Training in Track Engineering
Published by NR
on
December 1, 2006
This specification applies to all employers and people who undertake track engineering work on Network Rail controlled infrastructure. Purpose This specification sets out the minimum requirements for...
This document is referenced by:
NR/L2/OTK/5201 - Lineside Vegetation Management Manual
Published by NR
on
December 5, 2020
This manual contains: a) key principles for the management of risk; b) asset knowledge; and c) the impact of vegetation on other assets. The manual applies to inspecting, managing and maintaining...
This document is referenced by:
NR TWI 2C007 - How to Remove Seized Fastenings
Published by NR
on
March 1, 2005
Introduction This Track Work Instruction covers the removal of seized fastenings. See also separate instructions: TWI 2P006 How to tighten plain line fastenings TWI 2P017 How to carry out clipping &...
This document is referenced by:
NR TWI 2C014 - How to Referrule
Published by NR
on
March 1, 2005
Introduction This Track Work Instruction covers how to referrule baseplates and chairs. Ferrules are provided to take up any irregularities in chair/baseplate castings and to prevent metal to metal...
This document is referenced by:
NR TWI 2C016 - How to Install a Maintenance Screw
Published by NR
on
March 1, 2005
Introduction This Track Work Instruction covers the installation of a maintenance chair screw - known as an M screw. Note! A maintenance screw is intended as a replacement for a standard (AS)...
This document is referenced by:
NR TWI 2C018 - How to Recognise Inclined and Vertical Rail
Published by NR
on
March 1, 2005
Introduction This Track Work Instruction covers how to recognise vertical and inclined rail. See also the separate instruction: TWI 2T024 How to recognise twist rails