UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

NPFC - A-A-52034

DRAFTING INSTRUMENT SETS AND DRAFTING INSTRUMENTS

inactive
Buy Now
Organization: NPFC
Publication Date: 13 December 1991
Status: inactive
Page Count: 11

Document History

A-A-52034A VALID NOTICE 3
February 10, 2023
Drafting Instrument Sets and Drafting Instruments
A description is not available for this item.
A-A-52034
March 8, 2007
DRAFTING INSTRUMENT SETS AND DRAFTING INSTRUMENTS
A description is not available for this item.
A-A-52034A VALID NOTICE 1
September 27, 2001
DRAFTING INSTRUMENT SETS AND DRAFTING INSTRUMENTS
A description is not available for this item.
A-A-52034A
February 13, 1992
DRAFTING INSTRUMENT SETS AND DRAFTING INSTRUMENTS
The General Services Administration has authorized the use of this commercial item description in preference to Federal Specification GG-D-600D. This specification covers four drafting instrument...
A-A-52034
December 13, 1991
DRAFTING INSTRUMENT SETS AND DRAFTING INSTRUMENTS
A description is not available for this item.

References

This document references:
FED-STD-376 - PREFERRED METRIC UNITS FOR GENERAL USE BY THE FEDERAL GOVERNMENT
Published by NPFC on January 27, 1993
This standard lists preferred metric units (See 4.1) recommended for use throughout the Federal Government. It gives guidance on the selection of metric units required to comply with the provisions...
This document references:
ASTM B455/B455M - Standard Specification for Copper-Zinc-Lead Alloy (Leaded-Brass) Extruded Shapes
Published by ASTM on April 1, 2020
This specification establishes the requirements for extruded leaded-brass angles, channels, and other architectural shapes of solid cross section produced in Copper Alloy UNS Nos. C38000 and C38500....
This document references:
B36/B36M - Standard Specification for Brass Plate, Sheet, Strip, And Rolled Bar
October 1, 2023
This specification establishes the requirements for brass (copper-zinc alloy) plate, sheet, strip, and rolled bar of the following alloys: Units—The values stated in either inch-pound units or SI...
This document references:
B211/B211M - Standard Specification for Aluminum and Aluminum-Alloy Rolled or Cold Finished Bar, Rod, and Wire
October 1, 2023
This specification2 covers rolled or cold-finished bar, rod, and wire in alloys (Note 1) and tempers as shown in Table 2 [Table 3]. NOTE 1—Throughout this specification use of the term alloy in the...
View Less
View All
Advertisement