UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS ISO 18653

Gears - Evaluation of instruments for the measurement of individual gears

active, Most Current
Buy Now
Organization: BSI
Publication Date: 2 December 2003
Status: active
Page Count: 26
ICS Code (Gears): 21.200

Document History

BS ISO 18653
December 2, 2003
Gears - Evaluation of instruments for the measurement of individual gears
A description is not available for this item.

References

This document references:
ISO 1328-2 - Cylindrical gears — ISO system of flank tolerance classification — Part 2: Definitions and allowable values of double flank radial composite deviations
Published by ISO on February 1, 2020
This document establishes a gear tooth classification system relevant to double flank radial composite deviations of individual cylindrical involute gears and sector gears. It specifies the...
This document references:
ISO TR 10064-1 - Code of inspection practice — Part 1: Measurement of cylindrical gear tooth flanks
Published by ISO on September 1, 2019
This document supplements ISO 1328-1:2013. It provides a code of practice dealing with measurements on flanks of individual cylindrical involute gears, i.e. with the measurement of pitch, profile,...
This document references:
ISO 1328-1 - Cylindrical gears - ISO system of flank tolerance classification - Part 1: Definitions and allowable values of deviations relevant to flanks of gear teeth
Published by ISO on September 1, 2013
This part of ISO 1328 establishes a tolerance classification system relevant to manufacturing and conformity assessment of tooth flanks of individual cylindrical involute gears. It specifies...
This document references:
BS EN ISO 14253-1 - Geometrical product specifications (GPS) - Inspection by measurement of workpieces and measuring equipment Part 1: Decision rules for verifying conformity or nonconformity with specifications
Published by BSI on February 28, 2018
A description is not available for this item.
This document references:
ISO/IEC 17025 - General requirements for the competence of testing and calibration laboratories
Published by ISO on November 1, 2017
This document specifies the general requirements for the competence, impartiality and consistent operation of laboratories. This document is applicable to all organizations performing laboratory...
This document references:
ISO 1328-1 - Cylindrical gears - ISO system of flank tolerance classification - Part 1: Definitions and allowable values of deviations relevant to flanks of gear teeth
Published by ISO on September 1, 2013
This part of ISO 1328 establishes a tolerance classification system relevant to manufacturing and conformity assessment of tooth flanks of individual cylindrical involute gears. It specifies...
This document is referenced by:
BS PD ISO/TR 10064-5 - Code of inspection practice - Part 5: Recommendations relative to evaluation of gear measuring instruments
Published by BSI on December 5, 2005
A description is not available for this item.
View Less
View All

Related Products

Searching for related products...

Advertisement