UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

DOT - FAA-E-2042

CABLE, ELECTRICAL CONTROL, EXTERIOR

active, Most Current
Buy Now
Organization: DOT
Publication Date: 30 November 1977
Status: active
Page Count: 10

Document History

FAA-E-2042
July 11, 1979
CABLE, ELECTRICAL CONTROL, EXTERIOR
A description is not available for this item.
FAA-E-2042
November 30, 1977
CABLE, ELECTRICAL CONTROL, EXTERIOR
A description is not available for this item.

References

This document references:
B209/B209M REV A - Standard Specification for Aluminum and Aluminum-Alloy Sheet and Plate
December 1, 2021
This specification2 covers aluminum and aluminum-alloy flat sheet, coiled sheet, and plate in the alloys (Note 1) and tempers shown in Tables 2, 3, 4, and 5, and in the following finishes: Plate in...
This document references:
ASTM B3 - Standard Specification for Soft or Annealed Copper Wire
Published by ASTM on October 1, 2013
This specification covers drawn and annealed or soft round bare copper wire for electrical purposes (see Explanatory Note 1). The values stated in inch-pound units are to be regarded as standard. The...
This document references:
ASTM B8 - Standard Specification for Concentric-Lay-Stranded Copper Conductors, Hard, Medium-Hard, or Soft
Published by ASTM on April 1, 2011
This specification covers bare concentric-lay-stranded conductors made from round copper wires, either uncoated or coated with tin, lead, or lead alloy for general use for electrical purposes. These...
This document references:
ASTM D1248 - Standard Specification for Polyethylene Plastics Extrusion Materials for Wire and Cable
Published by ASTM on November 15, 2016
This specification provides for the identification of polyethylene plastics extrusion materials for wire and cable in such a manner that the seller and the purchaser can agree on the acceptability of...
This document references:
ASTM D470 - Standard Test Methods for Crosslinked Insulations and Jackets for Wire and Cable
Published by ASTM on January 15, 2021
These test methods cover procedures for testing crosslinked insulations and jackets for wire and cable. To determine the test to be made on the particular insulation or jacket, refer to the product...
This document is referenced by:
FAA-C-1391 REV D - INSTALLATION, TERMINATION, SPLICING, AND TRANSIENT/SURGE PROTECTION OF UNDERGROUND ELECTRICAL DISTRIBUTION SYSTEM POWER CABLES
Published by FAA on September 1, 2014
This specification defines the minimum requirements for the installation of medium voltage and low voltage (600 V) electrical line distribution (ELD) power cables buried directly in the earth or...
View Less
View All
Advertisement