UNLIMITED FREE
ACCESS TO THE WORLD'S BEST IDEAS

SUBMIT
Already a GlobalSpec user? Log in.

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

Customize Your GlobalSpec Experience

Select Your Free Newsletters

Industry Newsletters

Select Your Free Product Alerts

Finish!
Privacy Policy

This is embarrasing...

An error occurred while processing the form. Please try again in a few minutes.

BSI - BS EN 13190

Dial Thermometers

active, Most Current
Buy Now
Organization: BSI
Publication Date: 5 April 2002
Status: active
Page Count: 22
ICS Code (Temperature-measuring instruments): 17.200.20

Document History

BS EN 13190
April 5, 2002
Dial Thermometers
A description is not available for this item.
BS EN 13190
April 5, 2002
Dial Thermometers
A description is not available for this item.

References

This document references:
ISO 2768-1 - General Tolerances - Part 1: Tolerances for Linear and Angular Dimensions without Individual Tolerance Indications First Edition; (CEN EN 22768-1: 1993)
Published by ISO on January 1, 1989
This part of ISO 2766 is intended to simplify drawing indications and it specifies general tolerances for linear and angular dimensions without individual tolerance indications in four tolerance...
This document references:
IEC 60529 - Degrees of Protection Provided by Enclosures (IP Code)
Published by IEC on August 1, 2013
This standard applies to the classification of degrees of protection provided by enclosures for electrical equipment with a rated voltage not exceeding 72,5 kV.
This document references:
ISO 228-1 - Pipe Threads Where Pressure-Tight Joints Are Not Made on the Threads - Part 1: Dimensions, Tolerances and Designation
Published by ISO on September 1, 2000
This part of ISO 228 specifies the requirements for thread form, dimensions, tolerances and designation for fastening pipe threads, thread sizes 1/16 to 6 inclusive. Both internal and external...
This document references:
ASME B1.20.1 - Pipe Threads, General Purpose (Inch)
Published by ASME on November 15, 2013
This Standard covers dimensions and gaging of pipe threads of the following series: NPT NPSC NPTR NPSM NPSL
This document references:
BS ISO 10102 - Assembly tools for screws and nuts — Double-headed open-ended engineers' wrenches — Outside dimensions
Published by BSI on March 31, 2018
A description is not available for this item.
This document references:
ASME B1.20.1 - Pipe Threads, General Purpose (Inch)
Published by ASME on November 15, 2013
This Standard covers dimensions and gaging of pipe threads of the following series: NPT NPSC NPTR NPSM NPSL
This document is referenced by:
BS 2646-1 - Autoclaves for Sterilization in Laboratories - Part 1: Specification for Design, Construction, Safety and Performance
Published by BSI on March 15, 1993
Specifies requirements for the design, construction and performance of autoclaves operating with saturated steam at temperatures up to 138°C and pressure not exceeding 2.4 bar nominal and for...
View Less
View All

Related Products

Searching for related products...

Advertisement