4.1 This section provides a description of the environmental conditions listed in Section 1 and describes the sub-conditions within each condition. Examples provided for many of the conditions and sub-conditions are provided as guidance only. Each of the conditions described should be evaluated and...
4.1 This practice provides a method for the in-road installation of an inductive loop detector that consists of wire loops, lead-in wires, and lead-in cable. The practice is intended for installing wires in saw cuts made in the roadway surface and not for installing preformed loops that may be...
1.1 This specification covers the physical requirements for tools used to squeeze-off polyethylene (PE) pipe and tubing. It is limited to squeeze-off procedures set forth by the pipe manufacturer as referred to in Specification D2513 for gas pressure pipe systems. 1.2 Nothing in this...
These specifications cover the equipment making up the temporary grounding system used on de-energized electric power lines, electric supply stations, and equipment. These specifications for a system of protective grounding utilizing copper cables are covered in four...
This guide covers the design, performance, use, testing, and installation of temporary protective grounding (TPG) systems, including the connection points, as used in permanent and mobile substations. Purpose This guide suggests good practices, technical information, and safety...
This guide is primarily concerned with the collector system grounding for onshore wind power plants (WPPs). This guide is not intended for the WPP substation; however, since the substation is typically interconnected with the collector system, its design might affect or be...
This standard specifies aspects of planning and installation of bonding and grounding systems for telecommunications and information communication technology (ICT) systems and infrastructure within a customer premises (see Figure 2-1). This standard is intended to...
Narrow Your Results