loading
CANADIAN BUILDING CODE LL - NATIONAL BUILDING CODE OF CANADA
NRC
A description is not available for this item.
CANADIAN BUILDING CODE - NATIONAL BUILDING CODE OF CANADA
NRC
A description is not available for this item.
UL 2577 - Suspended Ceiling Power Grid Systems and Equipment
August 21, 2024 - ULSE

Suspended Ceiling Power Grid Systems and Equipment UL 2577 1.1 These requirements cover suspended ceiling grid low voltage/extra-low voltage systems and equipment intended for installation and use in accordance with the: In Canada: Canadian Electrical Code, Part I,...

UL 8752 - Organic Light Emitting Diode (OLED) Panels
May 16, 2024 - ULSE

Organic Light Emitting Diode (OLED) Panels UL 8752 1.1 These requirements apply to organic lighting emitting diode (OLED) panels intended for task, ambient, or aesthetic illumination, and for portable or permanent installation in accordance with the following standards, and for connection to...

UL 1993 - Self-Ballasted Lamps and Lamp Adapters
May 17, 2024 - ULSE

1.1 These requirements are intended to cover both self-ballasted lamps and self-ballasted lamp adapters rated 120 to 347 V AC nominal for connection to screw-base, pin-base, or recessed single contact (RSC or R7) lampholders. These devices are intended for use in accordance with the National...

UL 9741 - Electric Vehicle Power Export Equipment (EVPE)
September 29, 2023 - ULSE

1.1 The requirements of this standard apply to off-board unidirectional and bidirectional equipment rated 1000 Vac and 1500 Vdc or less, that transfers electrical energy between an electric vehicle and off board loads as well as operating in parallel with an electric power system, such as the...

UL 749 - Household Dishwashers
May 25, 2023 - ULSE

1.1 This Standard applies to electric household dishwashers intended to be used in nonhazardous locations in accordance with CSA C22.1, Canadian Electrical Code, Part I (CE Code, Part I) and the National Electrical Code (NEC), NFPA 70, on circuits having a nominal voltage not...

UL 486C - Splicing Wire Connectors
June 30, 2023 - ULSE

1.1 This Standard applies to single-polarity, hand-, or tool-applied splicing wire and cable connectors intended for use with all alloys of copper, aluminum conductors, or copper-clad aluminum conductors, or all three, in accordance with the Canadian Electrical Code Part I, CSA C22.1, in...

UL 248-1 - Low-Voltage Fuses - Part 1: General Requirements
October 24, 2022 - ULSE

1.1 This Standard applies to low-voltage fuses rated 1000 V or less, AC and/or DC, with interrupting ratings up to 300 kA (200 kA for Mexico). These fuses are intended to be used in accordance with the Canadian Electrical Code, Part I, CSA C22.1, NOM - 001, Mexican Electrical Code,...

UL 9540 - Energy Storage Systems and Equipment
June 28, 2023 - ULSE

1.1 These requirements cover an energy storage system (ESS) that is intended to receive and store energy in some form so that the ESS can provide electrical energy to loads or to the local/area electric power system (EPS) when needed. Electrochemical, chemical, mechanical, and thermal ESS are...

UL 248-13 - Low-Voltage Fuses - Part 13: Semiconductor Fuses
March 31, 2022 - ULSE

1.1 This Part is intended to be read together with the Standard for Low-Voltage Fuses - Part 1: General Requirements, hereafter referred to as Part 1. The titles of the Clauses in this Part correspond to the similarly titled Clauses in Part 1. The requirements of Part 1 apply unless modified...

UL 60947-1 - Low-Voltage Switchgear and Controlgear - Part 1: General Rules
May 31, 2022 - ULSE

1 Scope and object This standard applies, when required by the relevant product standard, to low-voltage switchgear and controlgear hereinafter referred to as "equipment" or "device" and intended to be connected to circuits, the rated voltage of which does not exceed 1 000 V a.c. or 1...

UL 2594 - Electric Vehicle Supply Equipment
December 15, 2022 - ULSE

1.1 This Standard applies to conductive electric vehicle (EV) supply equipment with a primary source voltage of 1000 V ac or less, with a frequency of 50 or 60 Hz, and intended to provide ac power to an electric vehicle with an on-board charging unit. This Standard covers electric vehicle...

UL 60335-2-40 - Household and Similar Electrical Appliances - Safety - Part 2-40: Particular Requirements for Electrical Heat Pumps, Air-Conditioners and Dehumidifiers
December 15, 2022 - ULSE

This clause of Part 1 is replaced by the following. This part of IEC 60335 deals with the safety of electric heat pumps , including sanitary hot water heat pumps , air conditioners , and dehumidifiers incorporating motor-compressors and hydronic fan coils units , their maximum rated voltages...

UL 60947-5-2 - Low-Voltage Switchgear and Controlgear - Part 5-2: Control Circuit Devices and Switching Elements - Proximity Switches
March 31, 2022 - ULSE

1 Scope and object This part of IEC 60947 applies to inductive and capacitive proximity switches that sense the presence of metallic and/or non-metallic objects, ultrasonic proximity switches that sense the presence of sound reflecting objects, photoelectric proximity switches that sense the...

UL 60947-5-1 - Low-Voltage Switchgear and Controlgear - Part 5-1: Control Circuit Devices and Switching Elements - Electromechanical Control Circuit Devices
May 31, 2022 - ULSE

1 Scope and object This part of IEC 60947 applies to control circuit devices and switching elements intended for controlling, signalling, interlocking, etc., of switchgear and controlgear. It applies to control circuit devices having a rated voltage not exceeding 1 000 V a.c. (at a frequency...

UL 60947-4-1 - Low-Voltage Switchgear and Controlgear - Part 4-1: Contactors and Motor-Starters - Electromechanical Contactors and Motor-Starters
May 31, 2022 - ULSE

This part of IEC 60947 applies to the types of equipment listed in 1 and 2 whose main contacts are intended to be connected to circuits the rated voltage of which does not exceed 1 000 V a.c. or 1 500 V d.c. Starters and/or contactors dealt with in this standard are not normally designed to...

UL 1576 - Flashlights and Lanterns
May 13, 2022 - ULSE

1.1 This standard applies to flashlights and lanterns powered by secondary (rechargeable) batteries and general purpose primary (non-rechargeable) batteries with a maximum voltage of 75 V d.c. The terms flashlights and lanterns as used within this standard refer to products that are...

UL 60335-2-24 - Household and Similar Electrical Appliances - Safety - Part 2-24: Particular Requirements for Refrigerating Appliances, Ice-Cream Appliances and Ice-Makers
July 29, 2022 - ULSE

This clause of Part 1 is replaced by the following: This International Standard deals with the safety of the following appliances, their RATED VOLTAGE being not more than 250 V for single-phase appliances, 480 V for other appliances and 24 V DC for appliances when battery operated: -...

UL 1008 - Transfer Switch Equipment
July 13, 2022 - ULSE

1.1 This standard applies to the following types of transfer switches that have a maximum rating of 1000 volts for use in non-hazardous locations, in accordance with Annex A1, Item 1: a) Automatic transfer switches; b) Manual or non-automatic transfer switches; c) Closed transition transfer...

Advertisement